Manuale d’uso / di manutenzione del prodotto SERIES 7 PFG del fabbricante Weil-McLain
Vai alla pagina of 16
Part No. 550-110-643/0605 T o complete boiler installation, follow: • General Information 2 • Boiler Wiring 3-5 • V ent Damper Installation 6 • Check-out Procedur e 7 • Operating Instruction.
2 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 GENERAL INFORMA TION: PLEASE GIVE THE MODEL listed on the boiler rating label AND THE CP NUMBER found next to the rating label. The following dened terms are used throughout this manual.
3 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 Section A: Installation 1. Bring supply wiring to boiler. Must be 14 ga. or heavier. See pages listed below each Figure for appropriate wiring diagram.
4 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 PFG-5.
5 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 PFG 6 thru 8.
6 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 These boiler s mus t have vent damper s: • PFG 5 (U.
7 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 1. See Figure 5 for operating instructions page numbers. Raise room thermostat to call for heat. Damper actuator will slowly open damper (if provided).
8 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 PFG-5 WITH HONEYWELL VR8204/VR8304 GAS V AL VE.
9 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 PFG-5 WITH WHITE-RODGERS 36C GAS V AL VE.
10 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 PFG 6-8 WITH ROBER TSHAW 7000 DERHC GAS V AL VE.
11 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 VERIFY PROPER OPERA TION AFTER SERVICING Nev er jumpe r (by pas s) any devi ce excep t for momentary testing as outlined in Troubleshooting Charts.
12 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 Check for open thermostat or circ. relay (where used) or check for loose wire connections, defective spill switch or rollout thermal fuse element, or open LWCO or limit c ontacts.
13 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 Check for open thermostat or circ. relay (where used) or check for loose wire connections, defective spill switch or rollout thermal fuse element, or open LWCO or hight limit contacts.
14 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 T ABLE III: Pilot Lights, Main V alve Will Not Come On With or Without V ent Damper Correct wiring. Make sure sense wire is not wrapped around any pipe or accessories.
15 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 T ABLE IV: Spark is Present, Pilot Will Not Light With or Without V ent Damper Connect securely to T er minals PV and MV/PV on ignition control.
16 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 Section E: Parts **Not for use on Canadian PFG-8 boilers. Only dampers listed above are approved for use on and PFG Series 6 & 7 boilers. Any other damper installed can cause severe personal injury or death.
Un punto importante, dopo l’acquisto del dispositivo (o anche prima di acquisto) è quello di leggere il manuale. Dobbiamo farlo per diversi motivi semplici:
Se non hai ancora comprato il Weil-McLain SERIES 7 PFG è un buon momento per familiarizzare con i dati di base del prodotto. Prime consultare le pagine iniziali del manuale d’uso, che si trova al di sopra. Dovresti trovare lì i dati tecnici più importanti del Weil-McLain SERIES 7 PFG - in questo modo è possibile verificare se l’apparecchio soddisfa le tue esigenze. Esplorando le pagine segenti del manuali d’uso Weil-McLain SERIES 7 PFG imparerai tutte le caratteristiche del prodotto e le informazioni sul suo funzionamento. Le informazioni sul Weil-McLain SERIES 7 PFG ti aiuteranno sicuramente a prendere una decisione relativa all’acquisto.
In una situazione in cui hai già il Weil-McLain SERIES 7 PFG, ma non hai ancora letto il manuale d’uso, dovresti farlo per le ragioni sopra descritte. Saprai quindi se hai correttamente usato le funzioni disponibili, e se hai commesso errori che possono ridurre la durata di vita del Weil-McLain SERIES 7 PFG.
Tuttavia, uno dei ruoli più importanti per l’utente svolti dal manuale d’uso è quello di aiutare a risolvere i problemi con il Weil-McLain SERIES 7 PFG. Quasi sempre, ci troverai Troubleshooting, cioè i guasti più frequenti e malfunzionamenti del dispositivo Weil-McLain SERIES 7 PFG insieme con le istruzioni su come risolverli. Anche se non si riesci a risolvere il problema, il manuale d’uso ti mostrerà il percorso di ulteriori procedimenti – il contatto con il centro servizio clienti o il servizio più vicino.