Manuale d’uso / di manutenzione del prodotto MPF50S Series del fabbricante Frymaster
Vai alla pagina of 30
Frymaster, a member of the Co mmercial Food Eq uipment Service Ass ociation, recomm ends using CFESA Certified Tec hnicians. 24-Hour Service Hotline 1-800-551-8633 MAR 2008 *8196301* MPF50S Series Por.
Please read all sections of this manual and retain for future reference. Installation, maintenance, and repairs shoul d be performed by your Frymaster Dean Factory Authorized Service Agency. WARNING Safe and satisfactory operation of y our equipment depends on its proper installation.
NOTICE: If this filter unit is cleaned with water, disconnect the unit from power source before cleaning and thoroughly dry the filter unit before reconnecting to electrical power source. DANGER The crumb tray (if equipped) in portable filter sy stems must be emptied into a fireproof container at the end of frying operati ons each day.
MPF50S Series Portable Filtration Systems Operation, Service & Parts Manual TABLE OF CONTENTS Page # 1. INTRODUCTION 1-1 2. IMPORTANT INFORMATION 2-1 3. FILTER PREPARATION 3-1 4. OPERATING/FILTER INSTRUCTIONS 4-1 5. CLEANING AND MAINTENANCE 5-1 6.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 1: INTRODUCTION 1-1 1.1 Parts Ordering Place parts orders directly with your local Frym as ter/Dean Factory Authorized Service Center. A list of FASCs was included with th e filter when shipped from the factory.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 1: INTRODUCTION 1-2 1.3 After Purchase In order to improve service, fill out the followi ng chart with the nearest Frymaster Authorized Service Technician and FASC in your area. Authorized Service Technician/FASC Address Telephone/Fax Filter Model Number Filter Serial Number 1.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 1: INTRODUCTION 1-3 1.5 Service Personnel 1.5.1 Definitions A. Qualified and/or Authorized Operating Pers onnel 1.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 2: IMPORTANT INFORMATION 2-1 2.1 General MPF50S portable filters can be used with a va riety of Frymaster fryers, as well as other manufacturers’ equipment. Oil capacity is appr oximately 50 pounds. Unit specifications are listed below.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 2: IMPORTANT INFORMATION 2-2 2.1 General (cont.) Oil or shortening is gravity-draine d from the fryer into the filter ("S" Models), or pumped from the frypot into the filter pan, and then filtered through filter p aper.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 2: IMPORTANT INFORMATION 2-3 2.3 Pre-Installation NOTE: Failure to use qualified service personnel will void the Fry master warranty. A. Standards : Use of this filter unit mu st be in accordance with all app licable state and local codes.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 3: FILTER PREPARATION 3-1 3.1 Assembling The Filter System On initial installation and before each use, rem ove all loose parts from the filter, wash all access ories in hot, soapy water and dry thoroughly.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 3: FILTER PREPARATION 3-2 3.1 Assembling The Filter System 1. Ensure the filter pan is clean a nd free of all food and breading pa rticles that could prevent the filter paper from sealing against the bottom of the pan.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 4: OPERATING/FILTERING INSTRUCTIONS 4-1 4.1 Filter Operation WARNING Use care when draining and filtering oil to avoid the possibility of a serious burn. 1. Sprinkle 8 ounces (1 cup) of filter po wder over the filter paper, distr ibuting the powder as evenly as possible.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 4: OPERATING/FILTERING INSTRUCTIONS 4-2 4.1 Filter Operation (cont.) 5. Ensure the oil is at operating temper ature, 350°F. Turn the fryer off. WARNING The filter pan maximum capacity is 50 lb s. DO NOT OVERFI LL THE FILTER PAN.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 5: CLEANING AND MAINTENANCE 5-1 5.1 General Cleaning operations fall into three general categories : • Wiping unit clean after e ach filter session; • Cleaning, changing filter paper and prepari ng the unit for the next day’s business.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 5: CLEANING AND MAINTENANCE 5-2 5.3 Daily— Close Of Business At the close of a working day, filter the oil in all f r yers.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-1 6.1 Operating Problems Plugged lines and plugged filter paper account for ove r 90 percent of filtrati on system m alfunctions. A general troubleshooting chart, included in this chapter, provides instructions in diagnosing common malfunctions.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-2 6.2 General Troubleshooting (cont.).
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-3 6.3 Wiring Diagrams 6.3.1 MPF50SS 115 2P 17P HEATER 1P 12P 11P 14P 15P 16P 4P 3P SWITCH FILTER LIGHT HEATER LIGHT FILTE R CONTROL SW ITCH PUMP M OTOR MOTOR PUMP GREEN WH I T E BLACK CORDSET GREEN WH I T E BLACK EXTERNAL CORD 115V OPTION 230V OPTION 6.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-4 6.4 Service Procedures 6.4.1 Replace Lights/Switches WARNING Disconnect power cord from elect rical power before servicing. 1. Disconnect power cord from power supply.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-5 6.4.2 Replace Heater Strip 1. Disconnect power cord from power supply. 2. Perform Step 2, Section 6.4.3.1, Replace Motor. 3. Remove screws securing outer panels and cord-holding bracket.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-6 6.4.2 Replace Heater Strip (cont.) 7. 115VAC Filters: Disconnect the black wire from the heater indica tor light on the switch panel (left, black arrow), and the white wire from the receptacle (white, white arrow).
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-7 6.4.3 Replace Motor/Pump 1. Disconnect power cord from power supply. 2. Perform Step 2, Section 6.4.1. Remove two screws securing the handle brackets to the control panel (arrows).
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-8 6.4.3.1 Replace Motor 4. Remove four bolts securing the pump to the motor. Leave the plumbing connected to the pump. Use care not to damage the flex supply lines connected to the pump.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-9 6.4.3.2 Replace Pump 1. Disconnect power cord from power supply. 2. Perform Steps 2 and 3, Section 6.4.3.1, Replace Motor. 3. Remove foil insulation tape and heater strip from pump and flex lines.
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-10 6.4.3.3 Replace Wand Hose 1. Disconnect power cord from power supply. 2. Remove cord-holder bracket and outer panels (see Step 3, Section 6.4.2 for reference).
MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 7: PARTS LIST 7-1 7.1 MPF50S Parts List.
MPF50S SERIES PORTABLE FILTRATION SYST EMS CHAPTER 7: PARTS LIST 7-2 Item Part # Description 1 823-6231 Pan, Filter 2 806- 5223SP Base Assembly (Includes items 3 & 4) 900-9542 Bracket, Motor-Mount.
MPF50S SERIES PORTABLE FILTRATION SYST EMS CHAPTER 7: PARTS LIST 7-3 24 912-2616 Bracket, Handle- Right 25 911-2616 Bracket, Handle- Left * 826-1380 Screw, ¼-20 x ½" Slotted Head (For Handle Bra cket) (Qty. of 5) 26 910-9169 Handle, Portable Filter * 826-1389 Bolt, ¼-20 x ¾" Hex Head (Qty.
Frymaster, L.L.C., 8700 Line Av enue, PO Box 51 000, Shreveport, Louisiana 71135-1000 Shipping Address: 8700 Line Av enue, Shreveport, Louisiana 71106 TEL 1-318-865-1711 FAX (Parts) 1-318- 219-71 40 F.
Un punto importante, dopo l’acquisto del dispositivo (o anche prima di acquisto) è quello di leggere il manuale. Dobbiamo farlo per diversi motivi semplici:
Se non hai ancora comprato il Frymaster MPF50S Series è un buon momento per familiarizzare con i dati di base del prodotto. Prime consultare le pagine iniziali del manuale d’uso, che si trova al di sopra. Dovresti trovare lì i dati tecnici più importanti del Frymaster MPF50S Series - in questo modo è possibile verificare se l’apparecchio soddisfa le tue esigenze. Esplorando le pagine segenti del manuali d’uso Frymaster MPF50S Series imparerai tutte le caratteristiche del prodotto e le informazioni sul suo funzionamento. Le informazioni sul Frymaster MPF50S Series ti aiuteranno sicuramente a prendere una decisione relativa all’acquisto.
In una situazione in cui hai già il Frymaster MPF50S Series, ma non hai ancora letto il manuale d’uso, dovresti farlo per le ragioni sopra descritte. Saprai quindi se hai correttamente usato le funzioni disponibili, e se hai commesso errori che possono ridurre la durata di vita del Frymaster MPF50S Series.
Tuttavia, uno dei ruoli più importanti per l’utente svolti dal manuale d’uso è quello di aiutare a risolvere i problemi con il Frymaster MPF50S Series. Quasi sempre, ci troverai Troubleshooting, cioè i guasti più frequenti e malfunzionamenti del dispositivo Frymaster MPF50S Series insieme con le istruzioni su come risolverli. Anche se non si riesci a risolvere il problema, il manuale d’uso ti mostrerà il percorso di ulteriori procedimenti – il contatto con il centro servizio clienti o il servizio più vicino.
