Manuale d’uso / di manutenzione del prodotto Split Oak Design, American Oak Design Unvented Propane Gas Log Heater Model Split Oak and American del fabbricante Desa
Vai alla pagina of 32
Save this manual for future reference. DESA INTERNA TIONAL UNVENTED (VENT -FREE) PROP ANE GAS LOG HEA TER ® Manually Control Models Also Designed Certified as V ented Decorative Appliance This appliance may be installed in an aftermarket* manufactured (mobile) home, where not prohibited by state or local codes.
2 103427 UNVENTED PROP ANE GAS LOG HEA TER SAFETY INFORMA TION DANGER: Carbon monoxide poisoning may lead to death! Carbon Monoxide Poisoning: Early signs of carbon monoxide poisoning re- semble the flu, with headaches, dizziness, or nausea. If you have these signs, the heater may not be working properly.
3 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS PRODUCT IDENTIFICA TION Figure 1 - Split Oak Design Model Left Front Branch Control Knob Rear Log Base Assembly Front .
4 103427 UNVENTED PROP ANE GAS LOG HEA TER DETERMINING AIR FLOW FOR HEATER LOCATION Determining if You Have a Confined or Unconfined Space Use this work sheet to determine if you have a confined or unconfined space.
5 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS AIR FOR COMBUSTION AND VENTILA TION Continued 4 . Compare the maximum Btu/Hr the space can support with the actual amount of Btu/Hr used.
6 103427 UNVENTED PROP ANE GAS LOG HEA TER NOTICE: Manual control heaters may be used as a vented product. If so, you must always run heater with chimney flue damper open. If running heater with damper open, non-combustible material above fireplace opening is not needed.
7 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS Heat Resistant Material (A) INST ALLA TION Continued Noncombustible Requirements for Material Distance (A) Safe Installation 12" or more Noncombustible material OK.
8 103427 UNVENTED PROP ANE GAS LOG HEA TER INSTALLING DAMPER CLAMP ACCESSORY FOR VENTED OPERATION Note: When used as a vented heater, appli- ance must be installed only in a solid-fuel burning fireplace with a working flue and constructed of non combustible material.
9 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS INST ALLA TION Continued INSTALLING HEATER BASE ASSEMBLY WARNING: If installing in a sunken fireplace, special care is needed. You must raise the fire- place floor to allow access to heater control panel.
10 103427 UNVENTED PROP ANE GAS LOG HEA TER Tee Joint Pipe Nipple Cap 3" Minimum Sediment Trap Gas Regulator From External Regulator (11" W.C.** to 14" W.C. Pressure) A.G.A. Design-Certified Manual Shutoff Valve With 1/8" NPT Tap* Approved Flexible Gas Hose (if allowed by local codes) CAUTION: Avoid damage to regulator.
11 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS INST ALLA TION Continued Pressure Testing gas Supply Piping system Test Pressures In Excess Of 1/2 PSIG 1. Disconnect heater and its individual manual shutoff valve from gas supply piping system.
12 103427 UNVENTED PROP ANE GAS LOG HEA TER Figure 22 - Installing Front Logs (#1L and #1R) Grate Prongs Metal Grate Bar Front Log (#1L) Notch Front Log (#1R) Right Front Branch (#5) Notches Left Fron.
13 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS INST ALLA TION Continued WARNING: Failure to posi- tion the parts in accordance with these diagrams or failure to use only parts specifically approved with this heater may result in property damage or personal in- jury.
14 103427 UNVENTED PROP ANE GAS LOG HEA TER Figure 28 - Pilot 8. T urn contr ol knob counterclockwise to desired hea ting level. The bur ners should light. Set control knob to any heat lev el between HI and LO. Thermocouple Ignitor Electrode Pilot Burner 1.
15 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS TO TURN OFF GAS TO APPLIANCE 1. Follow steps 1 thr ough 5 under Light- ing Instructions , page 14. 2. Depress contr ol knob and light pilot with match. 3. Keep contr ol knob pressed in f or 30 seconds after lighting pilot.
16 103427 UNVENTED PROP ANE GAS LOG HEA TER INSPECTING BURNERS Check pilot flame pattern and burner flame patterns often. PILOT FLAME PATTERN Figure 31 shows a correct pilot flame pat- tern. Figure 32 shows an incorrect pilot flame pattern. The incorrect pilot flame is not touching the thermocouple.
17 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS WARNING: If yellow tipping occurs, your heater could pro- duce increased levels of carbon monoxide. If front burner flame pattern shows yellow tipping, fol- low instructions at bottom of this page.
18 103427 UNVENTED PROP ANE GAS LOG HEA TER TROUBLESHOOTING Note: All troubleshooting items are listed in order of operation. WARNING: Turn off and un- plug heater and let cool before servicing. Only a qualified ser- vice person should service and repair heater.
19 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS TROUBLESHOOTING Continued OBSERVED PROBLEM One or both burners do not light after ODS/ pilot is lit Delayed ignition .
20 103427 UNVENTED PROP ANE GAS LOG HEA TER TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone.
21 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS OPTIONAL POSITIONING OF THERMOST A T SENSING BULB For Masonry and Factory- built Metal Fireplace If your log set cycl.
22 103427 UNVENTED PROP ANE GAS LOG HEA TER Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty.
23 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS LAVA ROCK - GA6060 For all models. Order when additional rock is desired. (3 lb. bag) DAMPER CLAMP - GA6080 For manually controlled models. Perma- nently opens chimney flue damper for vented operation.
24 103427 UNVENTED PROP ANE GAS LOG HEA TER ILLUSTRA TED PA R T S BREAKDOWN Variable Manually- Controlled Models 18 20 19 26 25 21 21 27 28 6 7 8 29 29 25 10 9 11 12 13 15 22 23 27-1 27-2 24 7-1 7-2 1.
25 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS P ARTS LIST Variable Manually-Controlled Models This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 22 of this manual.
26 103427 UNVENTED PROP ANE GAS LOG HEA TER 31 6 25 6 7 8 9 10 11 8 8 29 13 12 13 14 15 16 18 17 19 24 26 27 7-1 7-2 29 22 23 21 28 20 30 10-1 10-2 4 5 3 2 1R 1L ILLUSTRA TED PA R T S BREAKDOWN Thermo.
27 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS P ARTS LIST Thermostat-Controlled Split Oak Models This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 22 of this manual.
28 103427 UNVENTED PROP ANE GAS LOG HEA TER ILLUSTRA TED PA R T S BREAKDOWN Variable Manually-Controlled Models VL18PV VL24PV VL30PV 18 20 19 26 25 21 21 27 28 6 7 8 29 29 25 10 9 11 12 13 15 22 23 27.
29 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS P ARTS LIST Variable Manually-Controlled American Oak Models This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 22 of this manual.
30 103427 UNVENTED PROP ANE GAS LOG HEA TER NOTES _______________________________________________________________________________________________ ______________________________________________________.
31 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS NOTES _______________________________________________________________________________________________ _______________.
KEEP THIS WARRANTY W ARRANTY INFORMA TION Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard written warranty.
Un punto importante, dopo l’acquisto del dispositivo (o anche prima di acquisto) è quello di leggere il manuale. Dobbiamo farlo per diversi motivi semplici:
Se non hai ancora comprato il Desa Split Oak Design, American Oak Design Unvented Propane Gas Log Heater Model Split Oak and American Oak Design è un buon momento per familiarizzare con i dati di base del prodotto. Prime consultare le pagine iniziali del manuale d’uso, che si trova al di sopra. Dovresti trovare lì i dati tecnici più importanti del Desa Split Oak Design, American Oak Design Unvented Propane Gas Log Heater Model Split Oak and American Oak Design - in questo modo è possibile verificare se l’apparecchio soddisfa le tue esigenze. Esplorando le pagine segenti del manuali d’uso Desa Split Oak Design, American Oak Design Unvented Propane Gas Log Heater Model Split Oak and American Oak Design imparerai tutte le caratteristiche del prodotto e le informazioni sul suo funzionamento. Le informazioni sul Desa Split Oak Design, American Oak Design Unvented Propane Gas Log Heater Model Split Oak and American Oak Design ti aiuteranno sicuramente a prendere una decisione relativa all’acquisto.
In una situazione in cui hai già il Desa Split Oak Design, American Oak Design Unvented Propane Gas Log Heater Model Split Oak and American Oak Design, ma non hai ancora letto il manuale d’uso, dovresti farlo per le ragioni sopra descritte. Saprai quindi se hai correttamente usato le funzioni disponibili, e se hai commesso errori che possono ridurre la durata di vita del Desa Split Oak Design, American Oak Design Unvented Propane Gas Log Heater Model Split Oak and American Oak Design.
Tuttavia, uno dei ruoli più importanti per l’utente svolti dal manuale d’uso è quello di aiutare a risolvere i problemi con il Desa Split Oak Design, American Oak Design Unvented Propane Gas Log Heater Model Split Oak and American Oak Design. Quasi sempre, ci troverai Troubleshooting, cioè i guasti più frequenti e malfunzionamenti del dispositivo Desa Split Oak Design, American Oak Design Unvented Propane Gas Log Heater Model Split Oak and American Oak Design insieme con le istruzioni su come risolverli. Anche se non si riesci a risolvere il problema, il manuale d’uso ti mostrerà il percorso di ulteriori procedimenti – il contatto con il centro servizio clienti o il servizio più vicino.