Manuale d’uso / di manutenzione del prodotto SERIES 3000 GT 3200 del fabbricante Cub Cadet
Vai alla pagina of 44
IMPORTANT: READ SAFETY RULES A ND INSTRUCTIONS CAREFULLY Warning : This unit is e quipped with an internal combustion engine and should not be used on or near any unimproved forest-covered, brush-cove red or grass-covered land unless the en gine’s exhaust system is equipped with a spark arrester m eeting applicable local or st ate laws (if any).
2 TABLE OF CONTENTS PAGE TRACTOR PREPARTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 IMPORTANT SAFE OPERATION PRACTICES . . . . . . . . . . . . . . . . . . . . . 4 CALLING SERVICE INFORMATION . . . . . . . . . . . .
3 SECTION 1: TRACTOR PREPARATION Connect the Battery Battery posts, terminals and related accessories contain lead and lead c ompounds. Wash hands after ha ndling . The tractor is shi pped with a seale d battery, with the positive battery cabl e factory connected.
4 SECTION 2: IMPORTANT SA FE OPERATION PRACTICES WARNING : THIS SYMBOL PO INTS OUT IMPORT ANT SAFETY INSTRUCTIONS WHICH, IF N O T FOLLOWED, COULD EN DANGER THE PERSONAL SAFETY AND/OR PROPERTY OF YOURSELF AND OTHERS.READ AND FOLLOW ALL IN STRUCTIONS IN THIS MANUAL BEFORE ATTEMPTI NG TO OPE RATE YOUR UNIT.
5 • Never leave a running ma chine unattended. Always turn off b lade(s), place transmission in neutra l, set park brake, stop engine and remove key before dismounting.
6 • Avoid starting or stopping on a slope. If tires lose traction, dise n- gage the bl ade(s) and procee d slowly straight down the slope. • Follow the manufa cturers recom- mendations for wheel weights or counterweights to improve stability. • Use extra care with grass catchers or other attachments.
7 • To reduce fire hazard, keep the machine free of grass, leaves or other debris buil d-up. Clean up oil or fuel spillage. Allow machine to cool at least 5 minutes before storing. • Before cleaning, repairing or inspecting, make certa in the blade and all moving parts have stopped.
8 www.cubcadet.com CUB CADET LLC P. O. BOX 361131 CLEVELAND, OH 44136 DEALER LOCATOR PHONE NUMBER: 877-282-8684 Model Number Mfg. Date XXXXXXXXXXX XXXXXXXXXX SECTION 3: CALLING SERVICE INFORMATION The engine man ufacturer is responsib le for all eng ine-related issue s with regards to performance, powe r-rating, and specifications.
9 SECTION 5: SAFETY LABE LS FOUND ON YOUR UNIT Figure 2 TO ENSURE SAF E AND PROPER OPERATION OF TR ANS MISS ION, ONLY USE C UB CADE T DRIVE SYST EM FLUID PLUS .
10 SECTION 6: SLOPE GAUGE WARNING: Do not mow on inclines with a slope in excess of 15 degrees (a rise of app roximat ely 2-1/ 2 feet ever y 10 feet) .
11 A B C D E F G H I L M N O P Q R S Low Fuel Indicator Lamp Indicator Panel/Hour Meter Key Switch Module Parking Brak e Lever PTO Switch Brake Pedal Reverse Pedal Forward Pedal 12V Power Outlet Trans.
12 NOTE: References to LEFT and RIGHT indica te that side o f the tractor when facing forward while seated in the drivers seat. Reference to FRONT indicates the grille end of the tractor; to REAR, the drawbar end. Steering Wheel The steering wheel, centered on the dash panel, is used to turn the tractor left or right while drivi ng.
13 NOTE: A record of the actual h ours of operation should be kept to assure maintenance procedu res are com- pleted acco rding to the schedu le in this manual. The Indicator Monitor will also remind the operator of maintenance intervals for changing the engine oi l.
14 D . Parking Brake Le ver Figure 6 The parking brake lever is lo cated to the right of the steering w heel in the dash panel. With the brake pedal depressed fully, pu sh the parking brake lever do wnward and rel ease the brake pedal to lock the parking brake.
15 M. Fuel Fill Cap The fuel fill cap is located on th e fender to the left of the seat. N. Cup Holder The cup holder is loca ted on th e fender to the left of the seat. O . Hydrau lic Lift Leve r The hydraulic lift lever is located on the fender to th e left of the seat.
16 IMPORTANT: When u sing power take-off operated equipment, best performance is achieved with th e throttle lever in the “FAST” position. V . Choke Lever The choke lever is lo cated to the left of the steering whee l in the throttle/choke lever pod.
17 contin uously for mo re than 1 0 seconds at a tim e. If the engi ne does not start within this time, turn the key to “STOP” and wait a minute to allow the engine’ s starter motor to cool. Try again after waiting. • After the engin e starts, slowly release the brake pedal.
18 Driving On Slopes Refer to the SLOPE GAUGE on page 10 to help determine slopes where you may not operate safely. WARNING: Do not mow on inclin es with a slope i n excess of 15 degree s (a rise of approximately 2-1/2 feet every 10 fee t). The tractor could overturn and caus e serious injury.
19 Using the REVERSE CA UTION MODE k ey position The REVERSE CAUTION MO DE position of the key switch module allows the machine to be operated in reverse with the blades (PTO) engaged. IMPORTANT: Mowing in reverse is not recommended . Use extreme caution while operating the tractor in the “Reverse Caution Mode”.
20 Enga ging Differential Loc k Fully depress the diff. lock peda l to lock the transmission differential and provide constant pow er to both rear wheels when incre ased traction is needed. Release the diff. lock pedal when extra tractio n is not need ed.
21 SECTION 9: ADJUSTMENTS Seat Adjustment WARNING: Do not adjust the seat when the tractor is moving, a s this could cause the oper ator to lose co ntrol of the tractor. For the comfort of the ope rator, the tractor is equipped with an easy to operate adjustable seat.
22 Brake Inspection and Adjustment During no rmal operatio n, the tractor brake i s subject to minim al wear. How- ever, the brake should be perio dically tested, and adjusted if necessary. Checking the Brake. Place the tra ctor on a firm an d level surface.
23 SECTION 10: MAINTENANCE Maintena nce Char t † More often under dusty conditions †† Clean every 25 hours or more oft en under dusty or dirty condi tions NOTE: With the exception of utilizi ng the deck wash feature on the mower deck, we do not recommend the use of a pressure washer or ga rden hose to clean your tractor.
24 LUBRICATION ILLUSTRATION Cub Cadet 251H EP Gre ase or equivalent No. 2 lithium grease Engine Oil: See Figure 27 on page 34 Transmission Oil - Cub Cadet Drive Oil Can (High quality lubricating oil) .
25 Accessing Engine Compar tment The engine compartmen t can be accessed by raising the h ood as follows: • Lift the hood straight upward at th e recessed notches of the side panels to disengage the internal hood latch. • Carefully pi vot the hood fo rward to open.
26 with a solution of ammonia/w ater or baking soda/water. • NEVER connect (or disconnect) battery charger clips to the battery while the charger is turned on, as it can cause sparks. • Keep all sources of ign ition (ciga- rettes, matches, lighters) away from the battery.
27 Chargi ng the Batt er y Test and, if necessary, recharge the battery after the tractor has been stored for a period o f time. • A voltmeter or loa d tester should read 12.6 volts (DC) or higher across the battery terminals. • Charge the ba ttery with a 12-volt battery charger at a MAXIMUM rate of 10 amps.
28 then fully reinse rted before being withdrawn again for a true reading. Figure 21 Adding T ransmission Oil WARNING: The fluid for your transmission has been spe- cially formulated to ensure the safe and proper opera- tion of your tractor. Add Cub Cadet Drive System Fluid Plus ONLY.
29 Figure 22 • Clean around the base of the trans- mission oil filter and remo ve the filter by turning it counterclockwise. • Apply a light coating of clean trans- mission oil to the gasket of the new filter.
30 Fuse Fuses are instal led to protect the trac- tor’s electrical system from damage caused by excessive amperage. Always use the same capacity fuse for replacement. Refe r to the Specifica- tions Chart. If the electrical system does not function , check the fuses.
31 SECTION 11: ENGINE INFORMATION K OHLER CO . FEDERAL AND CALIFORNIA EM ISSION CONTROL SYSTEMS LIMITED W ARRANTY SMALL OFF-R O AD EQUIPMENT ENGINES The U.S. Environmental Protection Agency (EPA) , the California Ai r Resources Board (CARB), and Kohler Co.
32 LIMIT A TIONS This Emission Control System Warrant y shall not cover any of the following: (a) repair or replaceme nt required because of mi suse or neglect , improper maintenance, re pairs improperly perfor med or replacement not conforming to Kohler Co.
33 Cleaning The Engine This tractor has an air-cooled engi ne. Air must be able to circulate free ly around the engine through the flywheel screen, through the cooling shrouds and over the fins of the cylinder head an d cylinder block.
34 Refer to Figure 27 for information regarding the prope r type of oil to add to the crankcase. • Place the tracto r on a level surfa ce and engage the parking brake. Stop the tractor en gine and remove the ignition key. • Clean the area around th e oil filler cap to prevent debris from entering the crankcase.
35 • Attach the flexible tubing to the drain valve. Place an ap propriate container bel ow the open end of the tubing to collect the old oil . • To open the drain valve, push it slightly inward and turn it counterclockwise until it stops, the n pull it outward.
36 WARNING: Ope rating the engine with loose or dam- aged air clean er components will allow unfilt ered air into the carburetor , causin g ex- tensive wear and eventual failure of the engine. Servicing The Precleaner Wash and re-oil the fo am precleaner more often under ex tremely dusty or dirty conditi ons.
37 SECTION 12: TROUBLE SHOOTING P ossible Cause P ossible Remedy Har d T o Start No fuel in fuel tank or carburetor Fill the tank with fuel. Check the fuel line, car- buretor and fuel filter . Fuel line or carburetor clogged Clean the fu el line and carburetor with a com- mercial carburetor cleaner .
38 SECTION 13: OPTIONAL EQUIPMENT When purchasing your tractor, yo u probabl y had it equip ped for your particular needs at tha t time. You may later wi sh to obta in additional equipment or accessories to perfo rm other tasks.
39 SECTION 14: SPECIFICATIONS Engine Manufacturer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Kohler Horsepower . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25 Cylinders .
40 CALIFORNIA EMISSION CONTROL W ARRANTY ST A TEMENT Y OUR W ARRANTY RIGHTS AND OBLIGA TIONS The California Air Resources Boa rd and MTD Consumer Group Inc are pleased to explain the evaporative emission control system warrant y on your 2007 lawn mow er.
41 3. Any warranted part that is schedule d for replacement as required maintenance in the written instructions supplied is warranted for the period of time before the first scheduled replacement date for that part.
42 CUB CADET LLC MANUF A CTURER’S LIMITED W AR RANTY FOR 3000 SERIES GARDEN TRACT ORS RESIDENTIAL AND COMMERCIAL W ARRANTY The limited warranty set for th below is given by Cub Cadet L LC with respe.
43 Without limiting the f oregoing, this l imited warranty does not provide cov erage in the following cases: a. Routine maintenanc e items such as lubr icants, filters, b lad e shar pening , tune-ups, brak e adjustments, clutch adju stments, deck adjustments, and nor mal deter ioration of the exterior finish due to u se or e xposure.
SECTION 15: QUICK REFERENCE PARTS Description P ar t Number Engine Oil 737-3030A (10W3 0) 737-3049 (5W30) Air Filter KH-47-883-03 KH-24-083-02 Engine Oil Filter KH-12-050-08 Spark Plug 759-3336 T rans.
Un punto importante, dopo l’acquisto del dispositivo (o anche prima di acquisto) è quello di leggere il manuale. Dobbiamo farlo per diversi motivi semplici:
Se non hai ancora comprato il Cub Cadet SERIES 3000 GT 3200 è un buon momento per familiarizzare con i dati di base del prodotto. Prime consultare le pagine iniziali del manuale d’uso, che si trova al di sopra. Dovresti trovare lì i dati tecnici più importanti del Cub Cadet SERIES 3000 GT 3200 - in questo modo è possibile verificare se l’apparecchio soddisfa le tue esigenze. Esplorando le pagine segenti del manuali d’uso Cub Cadet SERIES 3000 GT 3200 imparerai tutte le caratteristiche del prodotto e le informazioni sul suo funzionamento. Le informazioni sul Cub Cadet SERIES 3000 GT 3200 ti aiuteranno sicuramente a prendere una decisione relativa all’acquisto.
In una situazione in cui hai già il Cub Cadet SERIES 3000 GT 3200, ma non hai ancora letto il manuale d’uso, dovresti farlo per le ragioni sopra descritte. Saprai quindi se hai correttamente usato le funzioni disponibili, e se hai commesso errori che possono ridurre la durata di vita del Cub Cadet SERIES 3000 GT 3200.
Tuttavia, uno dei ruoli più importanti per l’utente svolti dal manuale d’uso è quello di aiutare a risolvere i problemi con il Cub Cadet SERIES 3000 GT 3200. Quasi sempre, ci troverai Troubleshooting, cioè i guasti più frequenti e malfunzionamenti del dispositivo Cub Cadet SERIES 3000 GT 3200 insieme con le istruzioni su come risolverli. Anche se non si riesci a risolvere il problema, il manuale d’uso ti mostrerà il percorso di ulteriori procedimenti – il contatto con il centro servizio clienti o il servizio più vicino.
