Manuale d’uso / di manutenzione del prodotto GFCI del fabbricante Cal Spas
Vai alla pagina of 52
L TR20081000, Rev . D 8/12/08.
Copyright 2007-2008 Lloyds Material Supply , Inc. All rights reserved. Duplication without written consent is strictly prohibited. Cal Spas ® , Adjustable Therapy System™, A TS™, Bio-Clean™, Cal Zone Quest 2000™, Cal Premium™, Cal Select™, Cal Stone™ Ultimate Fitness Spa Series™, and XL Heat Exchanger™ are registered trademarks.
2008 Portable Spa Owner ’s Manual Page 1 L TR20081000, Rev . D Read This First! Read This First! Important Safety Instructions When installing and using this electrical equipment, always follow basic safety precautions. Following these instructions will help make your rst spa session a pleasurable one.
Page 2 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Read This First! jets, which will relax even the tightest muscles. In addition to the water pressure, you can add air into the spa water with air venturi handles located seat-side that increase the intensity of your massage.
2008 Portable Spa Owner ’s Manual Page 3 L TR20081000, Rev . D Preparing for Y our New Portable Spa Preparing for Y our New Portable Spa Most cities and counties require permits for exterior construction and electrical circuits.
Page 4 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Preparing for Y our New Portable Spa 120 V olt Electrical Installation Always follow applicable local, state and federal codes and guidelines. Use only a dedicated electrical line with a 20 amp breaker .
2008 Portable Spa Owner ’s Manual Page 5 L TR20081000, Rev . D Preparing for Y our New Portable Spa Spa Model GFCI Required Wires Required All 240V spas (except 6300 control boxes requiring high amp.
Page 6 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Preparing for Y our New Portable Spa Conguring the 6300 Control System The 6300 control system requires higher power than other 240V systems. Dip switch #10 is factory set in the ON position.
2008 Portable Spa Owner ’s Manual Page 7 L TR20081000, Rev . D Preparing for Y our New Portable Spa GFCI Wiring Diagram.
Page 8 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Preparing for Y our New Portable Spa Gas Heater Hook up Ultimate Fitness Series spa owners may buy and install a separate gas heater and pump for use with their spa. This option may be purchased separately from your local distributor .
2008 Portable Spa Owner ’s Manual Page 9 L TR20081000, Rev . D Preparing for Y our New Portable Spa.
Page 10 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Preparing for Y our New Portable Spa Filling and Powering Up Y our Portable Spa Once the spa has been placed on an approved 1. surface and has been correctly wired by a licensed electrician, inspect all plumbing connections in the equipment area of your spa.
2008 Portable Spa Owner ’s Manual Page 1 1 L TR20081000, Rev . D Operating Y our Spa Operating Y our Spa 5100, 6200 and 6300 Electronic Control Operation Initial Start up When rst powered up, it will automatically revert to Priming mode. A Pr on the topside display will indicate this.
Page 12 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Operating Y our Spa Light Press the Light button to turn on the light. Press it once again to turn the light off. All optional lighting such as the control panel light and cabinet perimeter lighting is controlled by the Light button and will turn on and off with the spa light.
2008 Portable Spa Owner ’s Manual Page 13 L TR20081000, Rev . D Operating Y our Spa HL A difference in readings between temperature sensors has been detected indicating a possible water ow problem. Make sure spa is lled to proper level and that pumps are primed (water is owing).
Page 14 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Operating Y our Spa When rst powered up, the 9800 electronic system will perform a self-diagnostic check and then it will automatically heat to and maintain a temperature of 100°F (37.
2008 Portable Spa Owner ’s Manual Page 15 L TR20081000, Rev . D Operating Y our Spa Jets 2 Press the “JETS 2” button once to turn pump 2 on or of f and to shift between low and high speeds if it is a two- speed pump. If left running, the pump will turn off after 15 minutes.
Page 16 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Operating Y our Spa Periodic Reminder Messages Press the “Mode” button to reset a displayed reminder . Message Frequency Action Required rPH Every 7 days T est and adjust chemical levels per manufacturer ’s instructions.
2008 Portable Spa Owner ’s Manual Page 17 L TR20081000, Rev . D Operating Y our Spa Message Meaning Action Required LF Persistent low ow problems. (Displays on the fth occurrence of the HFL message within 24 hours.) Heater is shut down, but other spa functions continue to run normally .
Page 18 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Operating Y our Spa Auxiliary Control Operation The auxiliary control option is available with the 9800 controls only . It is a small panel with four buttons that control certain spa functions, such as primary or additional jets, TV , or lights.
2008 Portable Spa Owner ’s Manual Page 19 L TR20081000, Rev . D Operating Y our Spa Adjustable Jets Almost all of the jets in your spa are adjustable. Rotating the face of an adjustable jet to the left (counter- clockwise) will decrease the amount of water ow through the jet.
Page 20 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Operating Y our Spa Adjustable Therapy System™ Pump On/Off This button allows the user to turn on and of f the A TS™ seat pump.
2008 Portable Spa Owner ’s Manual Page 21 L TR20081000, Rev . D W ater Quality Maintenance W ater Quality Maintenance Cal Spas Clear W ater Plan Great spa water is easily achieved when the right chemicals and / or systems are used and the Cal Spas Clear W ater Plan is implemented.
Page 22 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D W ater Quality Maintenance Bather Load “Bather Load” is the term used to describe the number of people using a spa, combined with the length of usage, and the frequency of usage. All these factors have a great effect on the spa water .
2008 Portable Spa Owner ’s Manual Page 23 L TR20081000, Rev . D W ater Quality Maintenance Chemical Descriptions The following descriptions and recommendations are intended for use with Cal Spas chemicals only . Many of these chemicals will be used with alternative sanitation systems as well.
Page 24 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D W ater Quality Maintenance For use with the chlorine Clear W ater Plan Chlorinating Granules Quick acting sanitizer / disinfectant for spa water . T est Strips – Chlorine Provides accurate spa water testing for bromine, pH, and total Alkalinity .
2008 Portable Spa Owner ’s Manual Page 25 L TR20081000, Rev . D W ater Quality Maintenance T raditional Chemical Start Up Prior to lling a spa for the rst time, or after a routine draining, you will want to follow this start-up plan to extend water life and performance.
Page 26 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D W ater Quality Maintenance Chlorine Clear W ater Plan This plan and its chemical dosages are intended for Cal Spas chemicals only . Most chemical manufacturers use different chemical formulas and strengths.
2008 Portable Spa Owner ’s Manual Page 27 L TR20081000, Rev . D W ater Quality Maintenance Place your extra clean lter cartridge back into the 5. spa. V acuum debris from the bottom of your spa with the 6. spa vacuum. Day T wo (Friday) T est spa water using chlorine test strips.
Page 28 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D W ater Quality Maintenance Use sodium bromide test strips (not bromine) and 12. adjust sodium bromide level to 7.4 to 8.2 (equates to 1700 to 2500 ppm TDS level). Add 2 oz of Cal Spas “Oxidizer Shock” to help burn 13.
2008 Portable Spa Owner ’s Manual Page 29 L TR20081000, Rev . D Cleaning and Maintenance Cleaning and Maintenance Removing and Reseating the Pillows Y ou can remove the pillows for cleaning and maintenance quickly and easily . This method works for all types of pillows.
Page 30 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Cleaning and Maintenance Draining Y our Portable Spa Y our spa should be drained every four to six months, and relled with fresh tap water . The following is the recommended method for draining your spa.
2008 Portable Spa Owner ’s Manual Page 31 L TR20081000, Rev . D Cleaning and Maintenance All-Purpose Cleaner (Spa Finish cleaning) Cal Spas™ All-Purpose Cleaner is an essential part of maintaining your spa’s nish. Through normal use, the spa’s nish can accumulate dirt, oil, and calcium causing a rough feel and unsightly scum lines.
Page 32 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Cleaning and Maintenance based wax that is specically formulated to protect the spa’s nish from the chemicals and minerals associated with normal spa use. The most effective solution to minimize cleaning time is prevention.
2008 Portable Spa Owner ’s Manual Page 33 L TR20081000, Rev . D Using the Entertainment System Some spas may be equipped with audio/visual entertain- ment options. Several options are available and include marine grade CD players, DVD players, and an iPod® docking station.
Page 34 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Using the Entertainment System Playing a CD Y ou can play CDs with any of the media systems (Sony or Aeware). Insert a disc in the disc drive as described above. 1. The player will identify the type of disc and begin playing it.
2008 Portable Spa Owner ’s Manual Page 35 L TR20081000, Rev . D Using the Entertainment System T o navigate the DVD menu on the TV screen, press the TRACK UP or TRACK DOWN buttons on the Aeware DVD player (not the remote control). Each time you press one of these buttons, the pointer on the TV screen will move from one selection to the next.
Page 36 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Using the Entertainment System Programming the Universal Remote Control The Cal Spas universal remote has been pre-pro- grammed to function with the entertainment system the spa has been congured with.
2008 Portable Spa Owner ’s Manual Page 37 L TR20081000, Rev . D Appendix Appendix Replacement Parts CXL W 6.5” POWER STORM JET DIRECTIONAL Standard gray PLU21703421 Stainless steel PLU21703622 CXW 5.
Page 38 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Appendix MNW 2.5”, NECK JET , QUAD BLASTER Standard gray PLU21703427 Stainless steel PLU21703628 MSRW / MFS 3”, STORM JET , MICRO SWIRL W/DRK EYEBALL Standard gray PLU21703433 Stainless steel PLU21703632 SFW 5.
2008 Portable Spa Owner ’s Manual Page 39 L TR20081000, Rev . D Appendix V alves PLU21300052 DIVERTER V AL VE 1” (2 W A Y) SIL VER, TEARDROP HANDLE (2 TONE) PLU21300062 DIVERTER V AL VE 2” (2 W .
Page 40 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Appendix Filters FIL1 1 100190 FIL TER CARTRIDGE, 50 SQ FT . ANTI-BACTERIAL RED FIL1 1 100191 FIL TER CARTRIDGE, 75 SQ FT . ANTI-BACTERIAL WHITE FIL1 1 100193 FIL TER CARTRIDGE, 35 SQ FT .
2008 Portable Spa Owner ’s Manual Page 41 L TR20081000, Rev . D Appendix Covers A valon Series A515/A526/A534 - 84 x 64 Standard Rust ACC01200460 Standard Gray ACC01200461 Standard Slate ACC01200464.
Page 42 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Appendix CLASSIC/LEGACY NEWPOR TER - 93 x 130 Standard Rust ACC01200450 Standard Gray ACC01200451 Standard Slate ACC01200452 Standard .
2008 Portable Spa Owner ’s Manual Page 43 L TR20081000, Rev . D Appendix DIJ-405 - 93 x 130 Deluxe Rust ACU02200540 Deluxe Gray ACU02200541 Deluxe Slate ACU02200542 Deluxe Palomino ACU02200543 Delux.
Page 44 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Appendix FII730B/L, FII745B/L - 84 x 84 Standard Rust ACC01200410 Standard Gray ACC0120041 1 Standard Slate ACC01200412 Standard Palom.
2008 Portable Spa Owner ’s Manual Page 45 L TR20081000, Rev . D Appendix Keeping Fit with your Spa IMPORT ANT : Always consult your physician before starting any exercise activity or program. The Ultimate Fitness series spas feature rubber exercise bands.
Page 46 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . D Appendix Connecting the Exercise Equipment The drawings below show different ways the exercise kit can be connected depending on the exercises you wish to do.
2008 Portable Spa Owner ’s Manual Page 47 L TR20081000, Rev . D Appendix Cal Spas™ Chemicals.
2008 W arranty U.S. and Canada Portable Spas This limited warranty is effective for portable spas manufactured after January 14, 2008 Manufacturer W arranty All Cal Spas hot tubs are manufactured with the highest quality appliances and are warranted to be free from defects in material and workmanship at the time of delivery .
2008 Portable Spa Owner ’s Manual Page 49 L TR20081000, Rev . D Appendix See your Cal Spas™ dealer for a copy of the applicable warranty , details, and any questions you may have regarding the warranty coverage on your spa.
Locating the product serial number The serial number of your spa is located on a metal plate attached to the lower right front panel of the spa.Y ou will need this number to properly register your spa and activate coverage. Write this information in the space provided below .
Un punto importante, dopo l’acquisto del dispositivo (o anche prima di acquisto) è quello di leggere il manuale. Dobbiamo farlo per diversi motivi semplici:
Se non hai ancora comprato il Cal Spas GFCI è un buon momento per familiarizzare con i dati di base del prodotto. Prime consultare le pagine iniziali del manuale d’uso, che si trova al di sopra. Dovresti trovare lì i dati tecnici più importanti del Cal Spas GFCI - in questo modo è possibile verificare se l’apparecchio soddisfa le tue esigenze. Esplorando le pagine segenti del manuali d’uso Cal Spas GFCI imparerai tutte le caratteristiche del prodotto e le informazioni sul suo funzionamento. Le informazioni sul Cal Spas GFCI ti aiuteranno sicuramente a prendere una decisione relativa all’acquisto.
In una situazione in cui hai già il Cal Spas GFCI, ma non hai ancora letto il manuale d’uso, dovresti farlo per le ragioni sopra descritte. Saprai quindi se hai correttamente usato le funzioni disponibili, e se hai commesso errori che possono ridurre la durata di vita del Cal Spas GFCI.
Tuttavia, uno dei ruoli più importanti per l’utente svolti dal manuale d’uso è quello di aiutare a risolvere i problemi con il Cal Spas GFCI. Quasi sempre, ci troverai Troubleshooting, cioè i guasti più frequenti e malfunzionamenti del dispositivo Cal Spas GFCI insieme con le istruzioni su come risolverli. Anche se non si riesci a risolvere il problema, il manuale d’uso ti mostrerà il percorso di ulteriori procedimenti – il contatto con il centro servizio clienti o il servizio più vicino.
