Manuale d’uso / di manutenzione del prodotto 544 del fabbricante Bolens
Vai alla pagina of 18
21” M ulchi ng M ow er Mode l 544 Oper ator ’ s Ma n ual PRI NTED IN U . S.A. 769-00447. fm (9/2002) IMPORT ANT : Re ad saf ety rules and instructi ons care fully bef ore ope ra ting eq uipment.
2 TAB LE OF CONTE NTS Conten t Page Import ant Safe O pera tion Pract ices .. ... ..... .. ..... .. .. ..... ... .... ... .. ..... .. ..... .. ... .... ... .... ... . 3 Slo pe Gau ge.... ... .... ... ..... .. .. ..... .. ..... .. ... ..... .. ..... ..
3 SECT IO N 1: IM PORTA NT SAF E OPE RATI ON PR ACTI CES General Operatio n 1. Read t hi s operator ’ s manual carefully in i ts ent i rety before a t tem pt ing to assemble this machine. Read , understand, and f oll ow all instructions on the machine and in t he ma nual (s) before operat i on.
4 imme diately and t he blade will s top rotating wit h in three seco nds. 9. Mow in daylight or good artificial light; walk, not run. 10. Stop th e bl ade wh en cr ossing grav el drives, walkways or roads. 11. If the equ i pment should start to vibrate abn orm ally, stop the eng i ne and check im mediately for the cause.
5 10. Ne v e r over f ill fuel tank. Fill tank t o no more than ½ inch below bottom of f iller neck to provide space for fuel expansio n. 11. Replace gas oline cap and tighten securely. 12. If gas ol ine is spilled, wipe it off the engine and equipme nt .
6 SECTION 2: SLOPE GAUGE Use t his page as a gui de to determine slopes where you may not operate safely. Do no t ope rat e your lawn mower on such slopes.
7 SECTION 3: ASSEMBLING YOUR LAWN MOWER Re movin g Unit From Car ton • Remove s t aples, brea k glue on top flaps, or cut tape at carton en d and open carton. • Remove loose pa r ts if included with unit (i.e., operator ’ s manua l, etc.) • Cut along corners, lay the carton down flat, and remove all pac k ing material.
8 • Remove hairpi n cli p from the outer hole of the weld pin on each hand le brackets. Using a pair of pliers, sque eze one leg of t h e l ower handle again s t the handle brack et. Insert the hairpin clip into the inner hole on the wel d pin. Re peat on the other sid e.
9 Fi gur e 9 Attach ing Grass Catcher T o Mower NOTE: Your law n mower is equi pped with both a mulching b af fle an d a mulching plug. While th e mulching baffle is located a t the rear of the mower, t he mulching pl ug i s located on the right of t he cutti n g deck.
10 SECTION 4: KNOW YOUR L A WN MOWER Read this operator ’ s ma nual and safety rules before operating y our lawn mowe r. Compare t he illustration in Fig ure 13 w ith yo ur lawn m ower to fam iliariz e you rself with the location of various controls and adjustment s.
11 SECTION 5: OPERATING Y OUR LAWN M OWER NOTE: For shipping purpos es y our mowe r is set with the wheels i n a l ow cutt i ng he i ght position . For best results, raise the cutting position until it is determined which height is best for your lawn.
12 Baggin g Grass Clippings You can use the grass catch er bag to collect clippings while you are o perating the mower. • Attach grass catcher following inst r uctions on page 9 of this manu al . Grass clippings will autom at ically collect in the bag as you run the mower.
13 SECTION 7: MAINTAINING YOUR LAWN MOWER Cle aning Mower The underside of the mower deck should be cleaned after each use to prevent an y build-up of grass clippings, leaves , dirt, or other debris. If t his de bri s is allo wed to a c cu mula te, it wi ll resu lt in rus t and corrosion.
14 SECTION 8: SERVICING THE MOWER Replacin g Rear Flap • To remove rear flap, cu t off the flat end of the wire rod which se c ures it to the deck. See Figure 17 . • Attach the new flap and new rod to deck, be nding the ends of the new rod over to secure to dec k .
15 SECTION 9: OFF-SEASON STORAGE St oring Y our Lawn Mower The following steps sh oul d be taken t o prepare your lawn mower for storage. • Clean and lubri cate m ower thoroughly as des cribed in the lubrication instruction s . IMPORT ANT : We do not recom mend the use of a pressure washer or garden hose t o clean your unit.
16 SECTION 11: PARTS LIST FOR MODEL 544 1 3 4 5 6 7 8 9 10 11 12 13 14 15 16 6 17 18 19 20 21 22 23 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 47 49 50 51 52 53 54 65 5.
17 Model 544 Ref. No. Pa r t No . P ar t Description 1. 749-10 92A Upper Handl e 2. 747-11 61A Control Handle 3. 710-12 70 C-Sunk Scr ew 1/4- 20 x 1.3 ” 4. 746-08 83 Thrott le Hous ing 5. 712-03 24 Hex Lo ck Nut 1/ 4-20 6. 720-02 79 Handle Kno b 7. 710-12 05 Rope Guide 8.
MANUF ACTURER ’ S LI MITED W ARRANTY FOR: The l imited warrant y set forth below is gi ve n by Troy -Bil t LLC with respect to new merch andise p urchased and u sed in t he Unit ed Stat es, it s posse ssi ons and t erri tori es.
Un punto importante, dopo l’acquisto del dispositivo (o anche prima di acquisto) è quello di leggere il manuale. Dobbiamo farlo per diversi motivi semplici:
Se non hai ancora comprato il Bolens 544 è un buon momento per familiarizzare con i dati di base del prodotto. Prime consultare le pagine iniziali del manuale d’uso, che si trova al di sopra. Dovresti trovare lì i dati tecnici più importanti del Bolens 544 - in questo modo è possibile verificare se l’apparecchio soddisfa le tue esigenze. Esplorando le pagine segenti del manuali d’uso Bolens 544 imparerai tutte le caratteristiche del prodotto e le informazioni sul suo funzionamento. Le informazioni sul Bolens 544 ti aiuteranno sicuramente a prendere una decisione relativa all’acquisto.
In una situazione in cui hai già il Bolens 544, ma non hai ancora letto il manuale d’uso, dovresti farlo per le ragioni sopra descritte. Saprai quindi se hai correttamente usato le funzioni disponibili, e se hai commesso errori che possono ridurre la durata di vita del Bolens 544.
Tuttavia, uno dei ruoli più importanti per l’utente svolti dal manuale d’uso è quello di aiutare a risolvere i problemi con il Bolens 544. Quasi sempre, ci troverai Troubleshooting, cioè i guasti più frequenti e malfunzionamenti del dispositivo Bolens 544 insieme con le istruzioni su come risolverli. Anche se non si riesci a risolvere il problema, il manuale d’uso ti mostrerà il percorso di ulteriori procedimenti – il contatto con il centro servizio clienti o il servizio più vicino.
