Manuale d’uso / di manutenzione del prodotto VPX5 126588 del fabbricante Vulcan-Hart
Vai alla pagina of 20
A product of VULCAN-HART LOUISVILLE, KY 40201-0696 F25111 (March 2002) - NOTICE - This Manual is prep ared for the use of trai ned Vulcan Servi c e Te ch nic ia ns and should not be us ed by those not properly qua li fied.
VPX SERIES STEAMERS F25111 (March 2002) Page 2 of 20 TABLE OF CONTENTS G E N E R A L ................................................................................ 3 Installation, O peration and Cleaning .............................................
VPX SERIES STEAMERS - GENERAL F25111 (March 2002) Page 3 of 20 GENERAL INSTA LLA T I ON, OPERA TION A ND CLEANING Refer to the Inst allat ion & Operation Manual for specific instructions.
VPX SERIES STEAMERS - REMOVAL AND REPLACEM ENT OF PART S F25111 (March 2002) Page 4 of 20 REMOVAL AND REPLACEMENT OF PARTS COVERS A ND PA NELS WA RNING: DISCONNECT THE ELECTR ICAL POW ER TO TH E MACHINE AT THE MAIN CIRCUIT BOX. PLACE A TAG ON THE CIRCUIT BOX INDICATI NG THE CIRCUIT IS BEING SERVICED.
VPX SERIES STEAMERS - REMOVAL AND REPLACEM ENT OF PART S F25111 (March 2002) Page 5 of 20 4. Reverse procedure to install replacement component and check steamer for proper operation.
VPX SERIES STEAMERS - REMOVAL AND REPLACEM ENT OF PART S F25111 (March 2002) Page 6 of 20 NOTE: Thermostat base is a brass 5/8" hex with a threaded stem. 4. Apply a small amount of "thermal transfer compound" to the mating surface (disk side) of the replacement thermostat.
VPX SERIES STEAMERS - REMOVAL AND REPLACEM ENT OF PART S F25111 (March 2002) Page 7 of 20 5. Remove mounting nuts & washers from the rear cooking compartment support legs and remov e base. 6. Disconnect heating element lead wires from element terminals.
VPX SERIES STEAMERS - REMOVAL AND REPLACEM ENT OF PART S F25111 (March 2002) Page 8 of 20 A. Temporarily install a flat washer and nut on all mounting studs. Hand tighten only . B. Tighten each nut to 100 in-lb using t he sequence as shown. C. Remove nut and washer from each mounting stud.
VPX SERIES STEAMERS - REMOVAL AND REPLACEM ENT OF PART S F25111 (March 2002) Page 9 of 20 5. Remove mounting nuts & washers from the rear cooking compartment support legs and remov e base. 6. Remove outer nut on drain valve stem and lift off drain handle assembly.
VPX SERIES STEAMERS - REMOVAL AND REPLACEM ENT OF PART S F25111 (March 2002) Page 10 of 20 Gasket 1. Open the door. 2. Remove screws from the gask et plate. 3. Pull the gasket plate out from the door housing and remove the gasket. 4. Position the new gasket on t he gasket plat e and reverse the procedure to install.
VPX SERIES STEAMER - SERVICE PROCEDURES AND ADJUSTM ENTS F25111 (March 2002) Page 11 of 20 Latch A ssembly 1. Open the door. 2. Remove screws from the top and bottom of the door. 3. Pull the "inner" door panel out from the door housing with the gasket plate and gasket st ill attached.
VPX SERIES STEAMER - SERVICE PROCEDURES AND ADJUSTM ENTS F25111 (March 2002) Page 12 of 20 To adj u st : 1. Reinstall the st riker with t he slot pointing upwards and "hand tighten" nut only . 2. Close the door to cent er t he st rik er in the oval mounting hole.
VPX SERIES STEAMER - SERVICE PROCEDURES AND ADJUSTM ENTS F25111 (March 2002) Page 13 of 20 VOLTAG E KW PER ELEMENT AMPS PER ELEMENT OHMS PER ELEMENT 1 PH 3 PH 208 3 14.4 8.3 14.4 240 3 12.5 7.2 19.2 480 3 3.6 76.8 208 5 24.0 14.0 8.70 240 5 21.0 12.0 11.
VPX SERIES STEAMER - ELECTRICAL OPERATION F25111 (March 2002) Page 14 of 20 ELECTRICAL OPERATION COMP ONENT FUNCTI ON B u z z e r .................. Signals end of a "cook" cycle when cooking time expires. C o n t a c t o r ............... Supplies line v oltage to heat ing elem ent assembly.
VPX SERIES STEAMER - ELECTRICAL OPERATION F25111 (March 2002) Page 15 of 20 SEQUENCE OF OPERA TION W iring diagram 7264 will be used to explain the electrical sequence of operation. Time d Cooking Mode 1. Conditions. A. Steamer connected to correct voltage and is properly grounded.
VPX SERIES STEAMER - ELECTRICAL OPERATION F25111 (March 2002) Page 16 of 20 F. Door closed (door switch closed). G. Timer "off". H. Cooking compartment filled to the water level mark and below standby t em perature of 168 ° F (+5/-8). 2. Select "continuous" on the cooking mode switch.
VPX SERIES STEAMER - ELECTRICAL OPERATION F25111 (March 2002) Page 17 of 20 WIRING DI A GRAMS 208-240V.
VPX SERIES STEAMER - ELECTRICAL OPERATION F25111 (March 2002) Page 18 of 20 480V.
VPX SERIES STEAMER - TROUBLESHOOTING F25111 (March 2002) Page 19 of 20 TROUBLESHOOTING WA RNING: CERTAIN PROCEDURES IN THIS SECTION REQUIRE ELECT RICAL TESTS OR MEASUREMENTS W HILE POW ER IS APPLIED TO THE MACHINE. EXERCISE EXTREME CAUTION AT ALL TIMES.
VPX SERIES STEAMER - CONDENSED SPARE PARTS LIST F25111 (March 2002) Printed in U.S.A. CONDENSED SPARE PARTS LIST VPX3 & VPX5 PART NUMBER DESCRIPTION NOTES 844385 Door Gasket (VPX5) 844196 Door Gas.
Un punto importante, dopo l’acquisto del dispositivo (o anche prima di acquisto) è quello di leggere il manuale. Dobbiamo farlo per diversi motivi semplici:
Se non hai ancora comprato il Vulcan-Hart VPX5 126588 è un buon momento per familiarizzare con i dati di base del prodotto. Prime consultare le pagine iniziali del manuale d’uso, che si trova al di sopra. Dovresti trovare lì i dati tecnici più importanti del Vulcan-Hart VPX5 126588 - in questo modo è possibile verificare se l’apparecchio soddisfa le tue esigenze. Esplorando le pagine segenti del manuali d’uso Vulcan-Hart VPX5 126588 imparerai tutte le caratteristiche del prodotto e le informazioni sul suo funzionamento. Le informazioni sul Vulcan-Hart VPX5 126588 ti aiuteranno sicuramente a prendere una decisione relativa all’acquisto.
In una situazione in cui hai già il Vulcan-Hart VPX5 126588, ma non hai ancora letto il manuale d’uso, dovresti farlo per le ragioni sopra descritte. Saprai quindi se hai correttamente usato le funzioni disponibili, e se hai commesso errori che possono ridurre la durata di vita del Vulcan-Hart VPX5 126588.
Tuttavia, uno dei ruoli più importanti per l’utente svolti dal manuale d’uso è quello di aiutare a risolvere i problemi con il Vulcan-Hart VPX5 126588. Quasi sempre, ci troverai Troubleshooting, cioè i guasti più frequenti e malfunzionamenti del dispositivo Vulcan-Hart VPX5 126588 insieme con le istruzioni su come risolverli. Anche se non si riesci a risolvere il problema, il manuale d’uso ti mostrerà il percorso di ulteriori procedimenti – il contatto con il centro servizio clienti o il servizio più vicino.
