Manuale d’uso / di manutenzione del prodotto LAUNCH 21V del fabbricante Supra
Vai alla pagina of 74
SUPRA - 1 © 2005 Skier’s Choice, Inc. T rademarks Supra, the Supra Logo, Comp L TS, Sunsport 22V , Sunsport 24V , Launch L TS, Launch 21, Launch 21V , Launch 22SSV , Launch 24SSV are registered trademarks of Skier ’ s Choice, Inc. All other product names are copyright and registered trademarks/trade names of their respective owners.
SUPRA - 2 © 2005 Skier’s Choice, Inc. T able of Content s Section I Introduction 3 Section II Boating Safety 5 Section III Boating Rules 1 1 Section IV Boat S pecifications 1 5 Section V Operating .
SUPRA - 3 © 2005 Skier’s Choice, Inc. Introduction Supra inboard ski boats are manufactured by Skier ’s Choice, Inc. in Maryville, T ennessee and distributed throughout the United S t ates and the world. This manual provides an overview for operating your Supra boat.
SUPRA - 4 © 2005 Skier’s Choice, Inc. • Drain Plugs (Securely in place?) • Life-Saving Devices (One for every person on board?) • S teering System (Working smoothly and properly?) • Fuel Sy.
SUPRA - 5 © 2005 Skier’s Choice, Inc. Section II Boating Safety Import ant Safety Information! Y our safety , as well as the safety of others with and around you, is a direct result of how you operate and maintain your boat. Read and comprehend this manual.
SUPRA - 6 © 2005 Skier’s Choice, Inc. Safety Equipment Y our Supra has been equipped at the factory with most of the federally required safety equipment for inland waters (Class 1, 16’-to-26’). This equipment includes: - UL-approved Marine Fire Extinguisher , T ype A-BC (2 lbs.
SUPRA - 7 © 2005 Skier’s Choice, Inc. General Safety Precautions - T o avoid serious personal injury , DO NOT be on or about the swim platform while engine is running and keep away from rear of boat while engine is running.
SUPRA - 8 © 2005 Skier’s Choice, Inc. Carbon Monoxide (CO) Safety Carbon monoxide is a colorless, odorless and tasteless gas. It is produced by gasoline engines and is a component of exhaust fumes. Shut off the engine when people are on the swim platform or in the water around the rear of the boat.
SUPRA - 9 © 2005 Skier’s Choice, Inc. Proper Seating Proper seating is an important element of boating safety . Proper seating consists of sitting with your buttock in full contact with a seat anytime the boat is underway and using hand holds and grab handles to secure oneself and prevent loss of balance.
SUPRA - 10 © 2005 Skier’s Choice, Inc. W arning Plates and Labels Read and note ALL warning plates and labels from bow to stern that appear on the boat, including these! If your warning decals should become damaged in any way , please contact your Supra Dealer or write to Skier ’ s Choice, Inc.
SUPRA - 11 © 2005 Skier’s Choice, Inc. Basic Boating Rules Y ou should be aware of these rules and follow them whenever you encounter another vessel on the water . The rules presented in this manual are condensed and have been provided as a convenience only .
SUPRA - 12 © 2005 Skier’s Choice, Inc. When two power-driven vessels are crossing each other ’s path close enough to run the risk of collision, the vessel that views the crossing vessel to the starboard (right) side must give-way .
SUPRA - 13 © 2005 Skier’s Choice, Inc..
SUPRA - 14 © 2005 Skier’s Choice, Inc..
SUPRA - 15 Section IV Boat Specifications Sunsport 22V Boat Specifications: Overall Length w/o Platform 21’ 8” Overall Length w/Platform 23’ 10” Overall Length w/Trailer 25’ 8” Width (Beam) 95” Draft 24” Weight - Boat Only 3,350 lbs. Weight - Boat & Trailer 4,450 lbs.
SUPRA - 16 © 2004 Skier ’s Choice, Inc. Sunsport 24V Boat Specifications: Overall Length w/o Platform 24’ Overall Length w/Platform 26’ Overall Length w/Trailer 27’ 4” Width (Beam) 102” Draft 26” Weight - Boat Only 3,950 lbs. Weight - Boat & Trailer 5,050 lbs.
SUPRA - 17 © 2004 Skier’s Choice, Inc. Launch 21V Launch 21 Boat Specifications: Overall Length w/o Platform 21’ 2” Overall Length w/Platform 23’ Overall Length w/Trailer 25’ 2” Width (Beam) 9 8 ” Draft 24” Weight - Boat Only 3,200 lbs.
SUPRA - 18 © 2004 Skier ’s Choice, Inc. Launch 24SSV Boat Specifications: Overall Length w/o Platform 24’ Overall Length w/Platform 26’ Overall Length w/Trailer 27’ 4” Width (Beam) 102” Draft 26” Weight - Boat Only 3,950 lbs. Weight - Boat & Trailer 5,050 lbs.
© 2004 Skier’s Choice, Inc. SUPRA - 19 © 2005 Skier’s Choice, Inc. Break In Period T aking care to properly break in your new engine will p ay off in the long run.
SUPRA - 20 © 2005 Skier’s Choice, Inc. Maximum Cap acities In compliance with United S tates Coast Guard Regulations, Supra Boats meet or exceed all safety st andards designed for recreational boats.
SUPRA - 21 A st andard pre-starting procedure should be always be followed before the first start-up of the day . 1. Check the engine oil level. 2. Check for gasoline fumes in bilge or engine compartment. 3 . Operate engine blower for 4 minutes before starting the engine to remove any fumes.
SUPRA - 22 © 2005 Skier’s Choice, Inc. Throttle Lever The Transmission Lockout button allows the transmission to be disengaged while giving the throttle full operating range. With the lever in the idle position (normally vertical) push the button located at the bottom of the lever to disengage the transmission.
SUPRA - 23 © 2005 Skier’s Choice, Inc. Bilge Area Center Drain Plug The bilge area center drain plug is located at the front of the motor well, directly under the engine. It is extremely important that the drain plug is always checked before st arting the engine.
SUPRA - 24 © 2005 Skier’s Choice, Inc. Filling the T ank Fuel Precautions Fueling The fuel cap is located on the rear deck near the stern. A special fuel key is provided to open the cap. NOTE: The cap is sealed by a rubber O-ring. Please do not over tighten.
SUPRA - 25 © 2005 Skier’s Choice, Inc. S peed Calibration S peed may be checked using a stopwatch and a st andard slalom course. Adjust the speedometer needle by turning the adjuster buttons.
SUPRA - 26 © 2005 Skier’s Choice, Inc. The speedometer indicates the water speed of the boat in miles per hour . It is recommended that the speedometer be checked for accuracy periodically . Speedometer Engine Hours are shown on the tachometer gauge located in the center of the dash p anel.
SUPRA - 27 © 2005 Skier’s Choice, Inc. This gauge indicates the approximate quantity of fuel remaining in the tank when the ignition is in the “ON” position.
SUPRA - 28 © 2005 Skier’s Choice, Inc. Depth Sounder Setting Units The depth sounder can display depth in either standard or metric units. Perform the following steps to change the display units: 1 . Simultaneously press the up and down buttons. Either the FT or M units indicator display text will flash.
SUPRA - 29 © 2005 Skier’s Choice, Inc. Out of Range Display If the display indicates three horizontal bars as shown, the depth sounder indicates an out of range, inaccurate or incomplete data condition. An out of range condition occurs when the depth reading is less than 2.
SUPRA - 30 © 2005 Skier’s Choice, Inc. Please refer to your stereo owner’s manual for proper operation instruction. NOTE: Stereo unit is connected to the S tereo switch on the switch p anel. The “Stereo” switch must be in the “ON” position before the stereo can be turned on.
SUPRA - 31 © 2005 Skier’s Choice, Inc..
SUPRA - 32 © 2005 Skier’s Choice, Inc..
SUPRA - 33 © 2005 Skier’s Choice, Inc. Horn Switch The Horn Switch is located on the port dash panel near the ignition. Sound the horn by depressing the button.
SUPRA - 34 © 2005 Skier’s Choice, Inc. T ilt Steering T ilt steering may be adjusted up or down in five different locking positions. T o adjust, depress the tilt lever located beneath the bezel and move the steering wheel to the desired position. Release the lever to lock the wheel into place.
SUPRA - 35 © 2005 Skier’s Choice, Inc. Gravity Ballast System The optional Gravity Ballast System is an electronically controlled ballast system that can be operated from the driver’s seat. The Gravity system is available in a 1, 2 or 3 position system.
SUPRA - 36 © 2005 Skier’s Choice, Inc. The Gravity Ballast system utilizes a manifold and a solenoid valve to independently fill each bag or tank. The solenoid valves have a small toggle switch that can manually override the opening of the valve.
SUPRA - 37 Ignition Keys T wo ignition keys are provided with the boat. Key entry into the ignition may be dif ficult due to the boot protector . Please, do not unduly force the key into the ignition. Key tumblers are located vertically , thus the key should be vertical when placed into the switch.
SUPRA - 38 © 2005 Skier’s Choice, Inc. The Rise-R Seat is a unique driver seat enhancement. The front edge of the driver ’s seat cushion lift s up to give the driver a taller sightline.
SUPRA - 39 © 2005 Skier’s Choice, Inc. V -Drive Ski Pylon The ski pylon is to be used to pull skiers. DO NOT use ski pylon to hoist boat! Only use the lifting rings for this purpose. The 24 Series boat has a retract able ski pylon. T o use, pull pylon up, twist counterclockwise and push back down into the lock position.
SUPRA - 40 © 2005 Skier’s Choice, Inc. Rad-A-Cage Style 1 T o Lower Cage For Storage T ools Required: 5/16” Allen Wrench 1 . Loosen (but do not remove) the front 5/16-18 x 1-1/4” allen head bolts that connect the front legs to the foot. 2. Remove the hand knobs of the rear feet.
SUPRA - 41 © 2005 Skier’s Choice, Inc. Pole Light Recept acle The pole light recept acle is located on the starboard of the stern, along side of the sun deck. T o install pole light, slide open the weather cover and insert the pole light in the aligned position.
SUPRA - 42 © 2005 Skier’s Choice, Inc. Lif ting Rings The forward bow eye is located just aft of the bow light. T wo lifting rings are located on the transom.
SUPRA - 43 © 2005 Skier’s Choice, Inc. Bilge Inspection Plate The fuel tank inspection plate/bilge inspection plate is located on the floor . Open the inspection plate by unscrewing it to check the condition of the fuel t ank and wire harness or for water in the bilge.
SUPRA - 44 © 2005 Skier’s Choice, Inc. The research and design team at Skier’s Choice has carefully explored and tested many different propellers and pitch angles for use on our boats.
SUPRA - 45 © 2005 Skier’s Choice, Inc. Hydraulic W ake Plate The hydraulic wake plate allows the driver to control the running attitude of the boat. It can be controlled by the switch on the dashboard. T rim Switch & Gauge This switch controls the optional hydraulic wake plate.
SUPRA - 46 © 2005 Skier’s Choice, Inc. Battery Box The battery is mounted inside the observer ’s seat storage compartment. Location may vary slightly depending on the model. NOTICE: It is recommended that the battery cables be disconnected from the battery when the boat is placed in storage.
SUPRA - 47 © 2005 Skier’s Choice, Inc. Optional T ower S peakers The optional tower speakers are an additional set of speakers designed to allow the rider to be able to hear the music. The tower speakers require the addition of an amplifier to power the speakers.
SUPRA - 48 © 2005 Skier’s Choice, Inc. The optional cockpit cover is a snap down storage cover designed to help protect the interior of your boat. T o install the cover , start at the windshield and work towards the transom. Be sure to install the cover poles to prevent water pocketing.
SUPRA - 49 © 2005 Skier’s Choice, Inc. Optional W alk-Through Curt ain Some Supra models offer an optional W alk-through curtain that snaps into the front walk-through to help prevent cool air from flowing into the cockpit area.
SUPRA - 50 © 2005 Skier’s Choice, Inc. Fuel Precautions Sp arks while fueling could cause an explosion! Before Fueling: 1. T urn off engine. 2. T urn off all electrical systems. 3. Extinguish cigarettes or any open flame. While Fueling: 1. Keep fuel hose nozzle in contact with fill pipe to provide grounding.
SUPRA - 51 The illustration above denotes the areas which may need to be accessed or may require cleaning or maintenance. It is important to have basic underst anding of the parts and their location on the boat. However , it is recommend that any service beyond routine maintenance be performed by an authorized Supra dealer .
SUPRA - 52 © 2005 Skier’s Choice, Inc. FRESH W A TER COOLING SYSTEM The standard cooling system for Supra boat s is an open circulation cooling system with intake water .
SUPRA - 53 © 2005 Skier’s Choice, Inc. V -Drive remote oil filter is mounted on the ski pylon bracket. V -Drive Remote Oil Filter The oil filter is located below the engine. The engine manufacturer recommends that you change the oil and oil filter after the first 10- 20 hours use of your new boat.
SUPRA - 54 © 2005 Skier’s Choice, Inc. Use only automatic transmission fluid type “A” in transmissions with 1:1 drive train. Refer to Engine Owners Manual. Change Frequency Change transmission fluid every year , using only Dextron-III Mercon automatic transmission fluid.
SUPRA - 55 The Shaft Log Packing Nut should be checked periodically and adjusted if needed. Adjust as follows: - Loosen the jam nut a few turns. - T ighten the shaft log packing nut by hand. DO NOT over tighten. - T ighten the jam nut against the packing nut.
SUPRA - 56 © 2005 Skier’s Choice, Inc..
SUPRA - 57 © 2005 Skier’s Choice, Inc. Section X Cleaning, Care & S torage W ashing and waxing the boat hull and deck regularly will extend the life and beauty of your Supra. It is a good routine to rinse your boat with fresh water after each day’ s use.
SUPRA - 58 © 2005 Skier’s Choice, Inc. All upholstery items on your Supra are made of tough marine grade vinyl that is easily cleaned. It is important to provide for the drying of all upholstery and carpet after each use of the boat.
SUPRA - 59 © 2005 Skier’s Choice, Inc. Section XI Winterization & Dry S torage When the boating and ski season comes to a close, it is important to have your boat professionally winterized. If your boat is exposed to temperatures below 32 degrees F (0 degrees C) it is possible for water in the engine, ballast system, heater core, etc.
SUPRA - 60 © 2005 Skier’s Choice, Inc. If the boat ever needs to be hoisted, special attention should be given to the following recommendations: - Hoist the boat using a horizontal lifting bar only . - Never attempt to lift the boat by means of a cable sling from bow to stern lifting eyes.
SUPRA - 61 © 2005 Skier’s Choice, Inc. Section XII T echnical Information The hull identification number is located on the upper right hand side of the transom below the rub rail. Identification Number Hydrogen and oxygen gases are produced during normal battery operation or charging.
SUPRA - 62 © 2005 Skier’s Choice, Inc..
SUPRA - 63 © 2005 Skier’s Choice, Inc. When connecting the trailer to your tow vehicle use the following procedure: 1. Raise the tongue with the trailer jack, position the trailer tongue directly over the 2" ball, and lower the jack until the tongue goes all the way down over the ball.
SUPRA - 64 © 2005 Skier’s Choice, Inc. Prolong T railer Life Connecting the T railer T railer Alignment When pulling the boat onto the trailer , be sure that it is centered on the trailer . The dist ance between the boat and the wheel runner board should be equal on both sides.
SUPRA - 65 © 2005 Skier’s Choice, Inc. NOTE: DO NOT attempt to use excessive power to free the boat from dry carpet runners. Power off of the trailer only when the boat has floated free. If the trailer is not submerged to the correct depth, the bow of the boat could drop when powering off incorrectly , possibly damaging the boat.
SUPRA - 66 © 2005 Skier’s Choice, Inc. Y our Supra trailers come standard with a trailer Boat Buddy . This featue makes loading your boat on the trailer much easier . Loading Place the trigger inthe “SET” position. When the bow eye contact s the Boat Buddy , the pin will latch, securing the boat.
SUPRA - 67 © 2005 Skier’s Choice, Inc. Optional Swing T ongue With the optional swing tongue, you can shorten the trailer length for storage by pulling the pin and swing the tongue away to the side. DO NOT tow trailer without latch pin inst alled. Always install safety clip on end of latch pin.
SUPRA - 68 © 2005 Skier’s Choice, Inc..
SUPRA - 69 © 2005 Skier’s Choice, Inc. Supra Limited W arranty T aking care of our product af ter it becomes yours has always been “standard policy” at Skier’s Choice, Inc., the proud manufacturer of the Supra line of boats. And to further prove our point, we offer the following limited warranty .
SUPRA - 70 © 2005 Skier’s Choice, Inc. adjustments, connectors, tune-ups and wear items, such as, shaft packing, belts, hoses, filters, seals, gaskets, strut bushing, etc.
SUPRA - 71 Dealer ’ s Responsibility 1. The Dealer should provide the buyer with an adequate orientation in the general operation of the boat and review all systems and accessories included with the boat.
SUPRA - 72 © 2005 Skier’s Choice, Inc..
SUPRA - 73 © 2005 Skier’s Choice, Inc. A Accessory Power Switch 31, 32 Air Inflator—Sunsport 24V 49 B Ballast System - Gravity (Optional) 35-36 Battery & Cable Installation 55 Battery Box 4 6.
SUPRA - 74 © 2005 Skier’s Choice, Inc. S Safety Lanyard/Engine Shut-Off Switch 47 Safety Equipment 6 Satellite Radio (Optional) 49 Seat Adjustment 38 Service & Maintenance 51 Shaft Log Packing .
Un punto importante, dopo l’acquisto del dispositivo (o anche prima di acquisto) è quello di leggere il manuale. Dobbiamo farlo per diversi motivi semplici:
Se non hai ancora comprato il Supra LAUNCH 21V è un buon momento per familiarizzare con i dati di base del prodotto. Prime consultare le pagine iniziali del manuale d’uso, che si trova al di sopra. Dovresti trovare lì i dati tecnici più importanti del Supra LAUNCH 21V - in questo modo è possibile verificare se l’apparecchio soddisfa le tue esigenze. Esplorando le pagine segenti del manuali d’uso Supra LAUNCH 21V imparerai tutte le caratteristiche del prodotto e le informazioni sul suo funzionamento. Le informazioni sul Supra LAUNCH 21V ti aiuteranno sicuramente a prendere una decisione relativa all’acquisto.
In una situazione in cui hai già il Supra LAUNCH 21V, ma non hai ancora letto il manuale d’uso, dovresti farlo per le ragioni sopra descritte. Saprai quindi se hai correttamente usato le funzioni disponibili, e se hai commesso errori che possono ridurre la durata di vita del Supra LAUNCH 21V.
Tuttavia, uno dei ruoli più importanti per l’utente svolti dal manuale d’uso è quello di aiutare a risolvere i problemi con il Supra LAUNCH 21V. Quasi sempre, ci troverai Troubleshooting, cioè i guasti più frequenti e malfunzionamenti del dispositivo Supra LAUNCH 21V insieme con le istruzioni su come risolverli. Anche se non si riesci a risolvere il problema, il manuale d’uso ti mostrerà il percorso di ulteriori procedimenti – il contatto con il centro servizio clienti o il servizio più vicino.
