Manuale d’uso / di manutenzione del prodotto 600 SERIES del fabbricante Magikitch'n
Vai alla pagina of 18
L25-001 REV 1 (11/02) MAGIKITCH’N A MAYT AG COMP ANY 180 Penn Am Drive Quakertown, Penns ylv ania 18951-2435 USA Telephone 800-44 1-1492 Fax: (215 ) 538-3644 WEBSI TE: W WW. MA GI KI TCH N .CO M PN 31-01-10374 © 2000– Mag i Ki tch ’ n 600 SERIES GAS BROILER INSTALLATION – OPERATION - MAINTENANCE MAGIKITCH’N P.
L25-001 REV 1 (11/02) NOTICE: THE INSTRUCTIONS TO BE FOLLOWED IN THE EVENT THE ODOR OF GAS IS DETECTED ARE TO BE POSTED IN A PROMINENT LOCA TION. THESE INSTRUCTIONS SHALL BE OBT AINED FROM THE LOCAL GAS SUPPLIER. KEEP AREA AROUND APPLIANCES FREE AND CLEAR FROM COMBUSTIBLES.
L25-001 REV 1 (11/02) Table of Contents 1. Inst allation 2. Gas Hook Up 3. Gas Settings 4. Lighting Instructions 5. Initial Set Up 6. Cleaning and Maintenance 7.
L25-001 REV 1 (11/02) 1. INST ALLA TION Units are to be installed in non-combustible loca tions only to utilize a 0” minimum clearance to non-combustible construction. Not approved for installations in combustible constructions. This installation must conform to local codes.
L25-001 REV 1 (11/02) suggest a Dow Corning®, GE® or Permatex® s ilicone ‘RTV’ adhesive sealant or equivalent. (See NSF Basic Criteria C-2 for details). 2. GAS HOOK UP An adequate gas supply is imperat ive. Undersized lines or low-pressures will restrict the volume of gas required for satisfactory perform ance.
L25-001 REV 1 (11/02) 3. GAS SETTINGS Regulator pressure must be measured and adjusted before th e unit goes into service, following installation and when operational perfo rmance is in question. A soft blue flame, just short of a yellow tip, gives the best resu lts; combustion air can be adjusted by opening or closing the air shutter slightly.
L25-001 REV 1 (11/02) SMB 600 Series Models without safety pilot a.) Turn all burners to OFF. b.) Remove the top grid(s). d.) Turn the runner tube valve to ON. e.) Light the runner tube through the gap in the front of the coal support as shown. Note: If the runner tube does not light, wait a few seconds, then try again.
L25-001 REV 1 (11/02) RMB 600 Series -S Models with safety pilot 1. Turn all burners to OFF. 2. Remove the top grid. 3. Remove a radiant. 4. Turn the shut off valve to ON. 5. Press and hold the reset (blue) button on the safety pilot valve. Wait 15–30 seconds.
L25-001 REV 1 (11/02) 5. INITIAL SET-UP All Models PROPER SET UP OF THE BROILER - After the in stallation of the broiler by a qualified technician, a thorough cleaning is necessary. Afte r this cleaning, be sure the broiler is set up properly. TOP GRID - Your top cooking gr id has two positions, either fl at or tilted.
L25-001 REV 1 (11/02) RMB 600 Series models STAINLESS STEEL RADIANT - It is ve ry important that the stainl ess steel radiants are placed over the burners. This will prov ide radiant heat and protect the burners from dripping grease. PREHEATING - It is necessary to preheat a co ld broiler each time before cooking.
L25-001 REV 1 (11/02) COALS - Use only Magicoals supplied by MagiKitch'n. Do not use lava rock or other replacement coals. They do not perform as well or last as long as the Magicoals that were designed for this application. Place the coals ev enly across the surface of the coal support.
L25-001 REV 1 (11/02) 6. CLEANING AND MAINTENANCE DAILY CLEANING AND MAINTENANCE TOP GRID - The top grid can be cleaned in num erous ways. The recommended procedure is to remove the grid and clean the frame, tubes and angles on front, sides and back with steel wool.
L25-001 REV 1 (11/02) 8. TYPICAL 600 SERIES ILLUSTRATION ( Model RMB 636 shown ) Note: Your unit may vary from this typical diagram..
L25-001 REV 1 (11/02) 8. TYPICAL SMB 600 SERIES ILLUSTRATION (Model SMB 636 shown) Note: Your unit may vary from this typical diagram..
L25-001 REV 1 (11/02) 9. ACCESSORY / PARTS LIST FOR RMB/SMB 600 SERIES MODELS Not all parts are illustrated, nor ar e all parts are listed. If you need a part that is not listed here, call MagiKitch'n for a quote. Always have your model and unit serial numbers available when phoning or ordering.
L25-001 REV 1 (11/02) 10. WARRANTY ORIGINAL EQUIPMENT WARRANTY (For U.S. and Canada) MagiKich’n warrants to each original Buyer that it s electrically-heated or gas-fired charbroilers / outdoor grills will be free from defects in material and workmanship for the period specified below.
L25-001 REV 1 (11/02) card is not returned, then the warranty per iod will be deemed to have commenced on the date of invoice for the particular oven to the dealer or other intermediate customer, which may have the effect of reducing substantially the duration of the warranty period.
L25-001 REV 1 (11/02) P.O. BOX 501 CONCORD NH 03302-0501 509 ROUTE 3A BOW NH 03304 800-258-3708 603-225-6684 FAX 603-225-8497 WWW.PITCO.COM.
Un punto importante, dopo l’acquisto del dispositivo (o anche prima di acquisto) è quello di leggere il manuale. Dobbiamo farlo per diversi motivi semplici:
Se non hai ancora comprato il Magikitch'n 600 SERIES è un buon momento per familiarizzare con i dati di base del prodotto. Prime consultare le pagine iniziali del manuale d’uso, che si trova al di sopra. Dovresti trovare lì i dati tecnici più importanti del Magikitch'n 600 SERIES - in questo modo è possibile verificare se l’apparecchio soddisfa le tue esigenze. Esplorando le pagine segenti del manuali d’uso Magikitch'n 600 SERIES imparerai tutte le caratteristiche del prodotto e le informazioni sul suo funzionamento. Le informazioni sul Magikitch'n 600 SERIES ti aiuteranno sicuramente a prendere una decisione relativa all’acquisto.
In una situazione in cui hai già il Magikitch'n 600 SERIES, ma non hai ancora letto il manuale d’uso, dovresti farlo per le ragioni sopra descritte. Saprai quindi se hai correttamente usato le funzioni disponibili, e se hai commesso errori che possono ridurre la durata di vita del Magikitch'n 600 SERIES.
Tuttavia, uno dei ruoli più importanti per l’utente svolti dal manuale d’uso è quello di aiutare a risolvere i problemi con il Magikitch'n 600 SERIES. Quasi sempre, ci troverai Troubleshooting, cioè i guasti più frequenti e malfunzionamenti del dispositivo Magikitch'n 600 SERIES insieme con le istruzioni su come risolverli. Anche se non si riesci a risolvere il problema, il manuale d’uso ti mostrerà il percorso di ulteriori procedimenti – il contatto con il centro servizio clienti o il servizio più vicino.
