Manuale d’uso / di manutenzione del prodotto BODBAY del fabbricante Hearth and Home Technologies
Vai alla pagina of 24
SA VE THESE INSTRUCTIONS www .quadrare.com This manual contains instructions for Installation, Operation & Maintenance. Please read this entire manual before you install and use your new room heater . Failure to follow instructions may result in property damage, bodily injury , or even death.
BODEGA BA Y WOOD INSERT Page 2 August 20, 2008 R 435-1320B and Welcome to the Quadra-Fire Family ! H earth & Home T echnologies welcomes you to our tradition of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality , durability , and perfor - mance.
Page 3 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B SAFETY & OVER VIEW OF APPLIANCE Location & Sample of Serial Number Label ----------- 2 Dimensions -----------------------------------.
BODEGA BA Y WOOD INSERT Page 4 August 20, 2008 R 435-1320B DIMENSIONS T OP VIEW SIDE VIEW FRONT VIEW SERIAL NUMBER LABEL LOCA TION: ON BEADED CHAIN, LEFT SIDE BEHIND OUTER SKIN Hearth Extension A B C .
Page 5 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B A VOID FIRE: T o ensure that insulation or any other combustible material does not contact the chimney , a chimney inside the house must have at least 2 inches (51mm) of air space clearance around the chimney .
BODEGA BA Y WOOD INSERT Page 6 August 20, 2008 R 435-1320B IF INST ALLING THIS MODEL T O A MASONRY CHIMNEY , AL W A YS BE SURE THE CHIMNEY IS IN GOOD CONDITION AND THA T IT MEETS THE MINIMUM ST ANDARDS OF THE NA TIONAL FIRE PROTECTION ASSOCIA TION (NFP A) ST ANDARD 21 1.
Page 7 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B Floor Ceiling Caulk Floor (second Story) Non-Combustible Firestopping Material Minimum 1 inch (25mm) clearance from exterior chimney to sheat.
BODEGA BA Y WOOD INSERT Page 8 August 20, 2008 R 435-1320B 1. An outside air inlet must be provided for combustion and must remain clear of leaves, debris, ice and/or snow . It must be unrestricted while unit is in use to prevent room air starvation which can cause smoke spillage and an inability to maintain a re.
Page 9 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B MASONR Y FIREPLACE USING DIRECT -CONNECT METHOD Refer to: Clearances to Combustibles on page 4, Canadian Installation Requirements on page 1 1, Hearth Requirements on page 4 and Zero Clearance Adjustable Support Kit on page 15.
BODEGA BA Y WOOD INSERT Page 10 August 20, 2008 R 435-1320B F ACT OR Y BUIL T ZERO CLEARANCE FIREPLACE (USA INST ALLA T ONS ONL Y) Listed Liner Mantel SEAL DAMPER AREA OR FACE SEAL Figure 10A - Instal.
Page 1 1 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B INST ALLA TION IN CANADA MASONR Y and HEA T -CIRCULA TING (INST ALLA TIONS INTO F ACTORY -BUIL T FIREPLACES ARE PROHIBITED IN CANADA) Wheth.
BODEGA BA Y WOOD INSERT Page 12 August 20, 2008 R 435-1320B SECURING LINER T O CHIMNEY RING There are 2 options to secure the liner to the chimney ring: (See Figure 12A). Option One: If there is enough room on the top of the insert to work, hand bend the two tabs upward 90°.
Page 13 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B 1. Remove contents from box being careful not to scratch or damage trim pieces. 2. Lay the panel set face down on protective covering to prevent scratching the painted surface. 3. Secure panel set together with screws provided.
BODEGA BA Y WOOD INSERT Page 14 August 20, 2008 R 435-1320B BLOWER CORD LOCA TION Remove Bolt Remove Bolt Figure 14A Figure 14C Figure 14D Figure 14B - Right Side Location Black Red White Snap Disc Blower Control Box with Switch Cooling Fan Black Operating the Blower Control Box with Switch 1.
Page 15 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B ZERO CLEARANCE ADJUST ABLE TRIM SUPPORT , 2” to 10” Part No. 841-0990, size 9”d x 45”w and Part No.
BODEGA BA Y WOOD INSERT Page 16 August 20, 2008 R 435-1320B WOOD SELECTION AND STORAGE Burn only dry seasoned wood. Dry , well-seasoned wood will not only minimize the chance of creosote formation but will give you the most efcient heat output.
Page 17 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B BURN RA TES ST ARTING FIRE : Open both controls (push in) completely . After a wood load has been burning on high for 5 to 15 minutes or longer for very large pieces, close the Start-Up Air Control (bottom rod) by pulling it out.
BODEGA BA Y WOOD INSERT Page 18 August 20, 2008 R 435-1320B AIR QUALITY AND YOUR QUADRA-FIRE INSERT In recent years there has been an increasing concern about the quality of our air . Much of the blame for poor air quality has been placed on the burning of wood for home heating.
Page 19 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B MAINTENANCE CARE AND CLEANING OF PLA TED SURF ACES IMPORT ANT : Y ou must clean all the ngerprints and oils from the plated surfaces before ring the insert for the rst time.
BODEGA BA Y WOOD INSERT Page 20 August 20, 2008 R 435-1320B 1 1 2 2 3 4 4 4 4 4 4 4 4 4 4 6 6 4 4 5 2 6-1/8" 2-1/4" 5 5 Allen wrench on retainer bolt First tube has larger holes BRICK REPLACEMENT INSTRUCTIONS P ART 832-3500 The rebox of your insert is lined with high quality re - brick which has exceptional insulating properties.
Page 21 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B EXPLODED VIEW 1 10 2 3 4 5 6 7 8 9 1 1 12 13 14 15 16 17 18 24 19 20 21 22 23 Item Part Name 1 Strain Relief Bushing 2 Speed Control (Rheost.
BODEGA BA Y WOOD INSERT Page 22 August 20, 2008 R 435-1320B SER VICE P ARTS DC-BB-GD Door Crown, Gold DC-BB-NL Door Crown, Nickel SP-BB3044-GD Panel & Gold T rim Set, Small, 30-1/2”h x 44-5/8”.
Page 23 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B W arranty Policy LIMITED LIFETIME W ARRANTY The Hearth & Home T echnologies limited Lifetime Warranty guarantees that the following components will work as designed for the lifetime of the stove or Hearth & Home T echnologies will repair or replace them.
Page 24 August 20, 2008 435-1320B R • Do NOT discard this manual. • Important operating and maintenance instructions included. • Read, understand and follow these instruci- tons for safe installation and operation. • Leave this manual with party responsible for use and operation.
Un punto importante, dopo l’acquisto del dispositivo (o anche prima di acquisto) è quello di leggere il manuale. Dobbiamo farlo per diversi motivi semplici:
Se non hai ancora comprato il Hearth and Home Technologies BODBAY è un buon momento per familiarizzare con i dati di base del prodotto. Prime consultare le pagine iniziali del manuale d’uso, che si trova al di sopra. Dovresti trovare lì i dati tecnici più importanti del Hearth and Home Technologies BODBAY - in questo modo è possibile verificare se l’apparecchio soddisfa le tue esigenze. Esplorando le pagine segenti del manuali d’uso Hearth and Home Technologies BODBAY imparerai tutte le caratteristiche del prodotto e le informazioni sul suo funzionamento. Le informazioni sul Hearth and Home Technologies BODBAY ti aiuteranno sicuramente a prendere una decisione relativa all’acquisto.
In una situazione in cui hai già il Hearth and Home Technologies BODBAY, ma non hai ancora letto il manuale d’uso, dovresti farlo per le ragioni sopra descritte. Saprai quindi se hai correttamente usato le funzioni disponibili, e se hai commesso errori che possono ridurre la durata di vita del Hearth and Home Technologies BODBAY.
Tuttavia, uno dei ruoli più importanti per l’utente svolti dal manuale d’uso è quello di aiutare a risolvere i problemi con il Hearth and Home Technologies BODBAY. Quasi sempre, ci troverai Troubleshooting, cioè i guasti più frequenti e malfunzionamenti del dispositivo Hearth and Home Technologies BODBAY insieme con le istruzioni su come risolverli. Anche se non si riesci a risolvere il problema, il manuale d’uso ti mostrerà il percorso di ulteriori procedimenti – il contatto con il centro servizio clienti o il servizio più vicino.
