Manuale d’uso / di manutenzione del prodotto P61A-2 del fabbricante Harman Stove Company
Vai alla pagina of 28
R1 P61A-2 ! Pellet ! S tove ! Owners ! Manual SA VE ! THESE ! INSTRUCTIONS. Inst allation ! & ! Operating ! Manual R5 ìCe ! manuel ! est ! disponible ! en ! FranÁais ! sur ! demandeî SAFETY ! NOTICE PLEASE ! READ ! THIS ! ENTIRE ! MANUAL ! BEFORE ! YOU ! INST ALL ! AND ! USE ! YOUR ! NEW ! ROOM ! HEA TER.
2 P61A !! Pellet ! Stove Fig. ! 1.
3 P61A ! Pellet ! Stove T esting ! Lable 2 Assembly ! & ! Installation 4 Installation 5 V enting !!!!!!!!!! 6 Automatic ! Operation 1 2 ESP ! Control 1 6 Maintenance 1 7 T rouble ! Shooting 2 2 Fe.
4 P61A !! Pellet ! Stove !!!!! ! ! Assembly ! and ! Installation Unpacking The ! P61 ! is ! bolted ! to ! the ! skid ! to ! prevent ! movement during ! shipping. To ! free ! the ! stove ! from ! the ! skid ! you ! must ! remove the ! hold-down ! bolts ! in ! the ! rear ! of ! the ! pedestal ! base.
5 P61A ! Pellet ! Stove Installing Place ! the ! stove ! on ! a ! noncombustible ! floor ! protector that ! extends ! 6 ! inches ! to ! the ! front, ! 6 ! inches ! to ! the ! sides and ! 1 ! inch ! to ! the ! rear ! of ! the ! stove. ! The ! minimum ! floor protector ! material ! is ! 24 ! gauge ! sheet ! metal.
6 P61A !! Pellet ! Stove V enting Requirement s ! for ! T erminating ! the ! V enting W ARNING: ! V enting ! terminals ! must ! not ! be ! re- cessed ! into ! a ! wall ! or ! siding. NOTE: ! Only ! PL ! vent ! pipe ! wall ! pass-throughs and ! fire ! stops ! should ! be ! used ! when ! venting ! through combustible ! materials.
7 P61A ! Pellet ! Stove V enting A ! combustion ! blower ! is ! used ! to ! extract ! the ! com- bustion ! gases ! from ! the ! firebox. ! This ! causes ! a ! negative pressure ! in ! the ! firebox ! and ! a ! positive ! pressure ! in ! the venting ! system ! as ! shown ! in ! fig.
8 P61A !! Pellet ! Stove #2 ! Preferred ! method This ! method ! also ! provides ! excellent ! venting ! for normal ! operation ! but ! requires ! the ! stove ! to ! be ! installed farther ! from ! the ! wall.
9 P61A ! Pellet ! Stove #4 ! Installing ! into ! an ! existing chimney ! ( ! US ! only ! ) This ! method ! provides ! excellent ! venting ! for ! normal operation. !! This ! method ! also ! provides ! natural ! draft ! in the ! event ! of ! a ! power ! failure.
10 P61A !! Pellet ! Stove #6 ! Installing ! into ! an ! existing fireplace ! chimney ! ( ! US ! and Canada ! ) This ! method ! provides ! excellent ! venting ! for ! normal operation. !! This ! method ! also ! provides ! natural ! draft ! in the ! event ! of ! a ! power ! failure.
11 P61A ! Pellet ! Stove #8 ! Installing ! through ! the ! ceiling ! vent Through ! the ! ceiling ! vent, ! follow ! PLvent manufacturers ! recommendations ! when ! using ! wall ! and ceiling ! pass ! through. Fig. ! 14 No ! insulation ! or other ! combustible materials ! are allowed ! within ! 3" of ! the ! PL ! vent ! pipe.
12 P61A !! Pellet ! Stove The ! P61A ! pellet ! stove ! is ! more ! than ! just ! automatic ! ignition, ! it ! is ! also ! automatic ! temperature ! control. The ! automatic ! system ! will ! allow ! the ! fire ! size ! to ! be ! adjusted ! to ! match ! the ! heating ! needs ! and ! even ! put the ! fire ! out ! if ! necessary .
13 P61A ! Pellet ! Stove Starting ! First ! Fire Ignitor ! Switch ! to"AUTO"(up ! position) Make ! sure ! the ! unit ! is ! plugged ! into ! a ! 120 V AC, ! 60 ! HZ ! electrical ! source. ! The ! power ! light should ! be ! the ! only ! light ! lit.
14 P61A !! Pellet ! Stove The ! P61A ! Pellet ! Stove ! is ! capable ! of ! manual ! operation. ! This ! also ! allows ! the ! operator ! to manually ! control ! operation ! during ! an ! emergency ! (i.e. ! ignitor ! failure, ! when ! using ! a ! 502H ! battery backup, ! or ! when ! using ! certain ! generators.
15 P61A ! Pellet ! Stove P61A-2 !! MANUAL !! ST ART !! UP Starting ! First ! Fire Ignitor ! Switch ! to"MANUAL" (down ! position) Make ! sure ! the ! unit ! is ! plugged ! into ! a 120 ! V AC, ! 60 ! HZ ! electrical ! source. ! The power ! light ! should ! be ! the ! only ! light ! lit.
16 P61A !! Pellet ! Stove O O P61A-2 !! AUTOMA TIC ! IGNITION !! ESP !! CONTROL Feed ! adjuster Sets ! the ! maximum ! feed rate T est Runs ! all ! motors ! at ! full speed ! for ! one ! minute to ! check ! operation.
17 P61A ! Pellet ! Stove These ! units ! are ! pre-tested ! at ! the ! factory ! with ! exactly 120 ! V olts ! A.C., ! 60 ! Hz. ! They ! are ! checked ! and ! adjusted !! for firebox ! tightness, ! gasket ! leakage, ! motor ! operation ! and ! ignitor operation.
18 P61A !! Pellet ! Stove The ! room ! sensor ! is ! a ! small ! temperature ! sen- sor ! on ! the ! end ! of ! a ! 60" ! gray ! wire. ! This ! sensor ! is installed ! much ! like ! a ! standard ! wall ! thermostat.
19 P61A ! Pellet ! Stove Removing ! Ashes: When ! approximatly ! 1 ! ton ! of ! pellets ! has ! been burned ! it ! will ! be ! necessary ! to ! empty ! the ! ash ! pan. Ashes ! should ! be ! placed ! in ! a ! metal ! container with ! a ! tight ! fitting ! lid.
20 P61A !! Pellet ! Stove Latch ! "closed ! "with blower ! cover ! in ! place. Burn ! pot ! clean-out ! is closed. Latch ! "open ! "with ! blower cover ! partly ! removed. Burn ! pot ! clean-out ! is open. Exposed !! blower ! wheel and ! flue ! opening, NOTE: ! ESP ! probe ! is visible.
21 P61A ! Pellet ! Stove Burn ! Pot ! Cleaning ! and ! Maintenance 1. !! Scrape ! the ! top ! holed ! surface ! and ! sides ! of ! the ! burn pot.(Fig !! 34) ! It ! is ! not ! necessary ! to ! completely ! remove all ! material ! from ! the ! burn ! pot.
22 P61A !! Pellet ! Stove !! FEEDER ! DOES ! NOT ! FEED 1. ! No ! pellets ! in ! hopper . 2. ! Firebox ! draft ! may ! be ! too ! low ! for ! low ! draft ! pressure switch ! in ! feeder ! circuit ! to ! operate. ! Check ! for ! closed doors , ! loose ! or ! missing ! gasket ! on ! doors ! or ! hopper ! lid, faulty ! pressure ! switch.
23 P61A ! Pellet ! Stove W eight 24 9 ! lbs. Blower 13 5 ! cfm Feed ! Rate .75 ! to ! 7.5 ! lbs. ! per ! hr . Hopper ! Capacity 7 2 ! lbs. Fuel W o od ! Pellets Flue ! Size 3 ! inch Outside ! Air ! Size 2 ! 3/8 ! I.D. ! inch Fuse ! Rating 5 ! amp 32.375" 9" 23.
24 P61A !! Pellet ! Stove Door ! Options Optional ! T rim To ! install, ! lay ! the ! frame ! face ! down ! on ! a ! sof t surface. !! Fasten ! door ! frame ! by ! inserting ! the ! 4 threaded ! post s ! on ! the ! frame ! through ! the ! door .
25 P61A ! Pellet ! Stove OPTIONS Side ! Heat ! Shields Side ! heat ! shields ! are ! available ! to ! reduce the ! clearance ! to ! combustible ! materials. Hopper ! Extension The ! hopper ! extension ! allows ! you ! to put ! more ! pellet ! fuel ! in ! the ! hopper ! and ! extends burn ! time ! on ! one ! load ! of ! pellets.
26 P61A !! Pellet ! Stove P61A-2 ! Wiring ! Diagram.
27 P61A ! Pellet ! Stove Description Part ! Number Hopper ! Gasket(6 ! ft.) 0-88-00248 Ash ! Pan ! Assembly 1-10-05800 Burn ! Pot ! Weldment 1-10-05802 Right ! Rear ! Shield 2-00-06468-1 Left ! Rear !.
28 P61A !! Pellet ! Stove Harman ! S tove ! Company ! warrants ! its ! products ! to ! be ! free ! from ! defects ! in ! material ! or ! workmanship, ! in ! normal ! use and ! service, ! for ! a ! per.
Un punto importante, dopo l’acquisto del dispositivo (o anche prima di acquisto) è quello di leggere il manuale. Dobbiamo farlo per diversi motivi semplici:
Se non hai ancora comprato il Harman Stove Company P61A-2 è un buon momento per familiarizzare con i dati di base del prodotto. Prime consultare le pagine iniziali del manuale d’uso, che si trova al di sopra. Dovresti trovare lì i dati tecnici più importanti del Harman Stove Company P61A-2 - in questo modo è possibile verificare se l’apparecchio soddisfa le tue esigenze. Esplorando le pagine segenti del manuali d’uso Harman Stove Company P61A-2 imparerai tutte le caratteristiche del prodotto e le informazioni sul suo funzionamento. Le informazioni sul Harman Stove Company P61A-2 ti aiuteranno sicuramente a prendere una decisione relativa all’acquisto.
In una situazione in cui hai già il Harman Stove Company P61A-2, ma non hai ancora letto il manuale d’uso, dovresti farlo per le ragioni sopra descritte. Saprai quindi se hai correttamente usato le funzioni disponibili, e se hai commesso errori che possono ridurre la durata di vita del Harman Stove Company P61A-2.
Tuttavia, uno dei ruoli più importanti per l’utente svolti dal manuale d’uso è quello di aiutare a risolvere i problemi con il Harman Stove Company P61A-2. Quasi sempre, ci troverai Troubleshooting, cioè i guasti più frequenti e malfunzionamenti del dispositivo Harman Stove Company P61A-2 insieme con le istruzioni su come risolverli. Anche se non si riesci a risolvere il problema, il manuale d’uso ti mostrerà il percorso di ulteriori procedimenti – il contatto con il centro servizio clienti o il servizio più vicino.
