Manuale d’uso / di manutenzione del prodotto (V)KC36PE SERIES, (V)KC36NE SERIES del fabbricante Desa
Vai alla pagina of 40
For more information, visit www .desatech.com W ARNING: If the information in this manual is not fol- .
www .desatech.com 1 16238-01E 2 SAFETY INFORMA TION T ABLE OF CONTENTS Safety Information ............................................... 2 Product Identication ........................................... 4 Local Codes..............................
www .desatech.com 1 16238-01E 3 This replace must be installed by a qualied (cer - tied or licensed) service person. It has a sealed gas combustion chamber that uses a coaxial pipe (pipe within a pipe and having the same center) venting system.
www .desatech.com 1 16238-01E 4 2. If you smell gas • shut off gas supply • do not try to light any appliance • do not touch any electrica l switch; do not use any phone in your building • immediately call your gas supplier from a neighbor ’ s phone.
www .desatech.com 1 16238-01E 5 PRODUCT FEA TURES These are a few facts that can help you understand and enjoy your direct-vent replace: • The venting system may be routed to the out - side of your home in several ways. It may vent through the roof (vertical) or it may vent to an outside/exterior wall (horizontal).
www .desatech.com 1 16238-01E 6 • Y our replace is designed to be used in zero clea ranc e install atio ns. W all or fram ing mater ial can be placed directly against any exterior sur - face on the back, sides or top of your replace, except where standoff spacers are integrally atta ched .
www .desatech.com 1 16238-01E 7 A B E F G H D C Nailing T abs Figure 4 - Framing Clearances for Installation Against an Exterior Wall 36 1 / 8 " 41 1 / 4 " 21" Horizontal V ent 24 1 / 2.
www .desatech.com 1 16238-01E 8 Figure 7 - Minimum Clearances for T ermination Cap LOCA TION OF TERMINA TION CAP Fixed Closed Op en ab le Fixed Closed V V V V V V V V X X V X G G J F B B K N H I A N E.
www .desatech.com 1 16238-01E 9 VENT ING INST ALLA TION INSTRUCTIONS NOTICE: Read these instruc- .
www .desatech.com 1 16238-01E 10 INST ALLA TION pLANNING There are two basic types of direct-vent in - stallation: • Horizontal T ermination • V ertical T ermination Horizontal T ermination Installation IMPORTANT : Horizontal square terminations require only inner portion of wall restop.
www .desatech.com 1 16238-01E 1 1 VENTING INST ALLA TION INSTRUCTIONS Continued W ARNING: Do not recess 6.
www .desatech.com 1 16238-01E 12 VENTING INST ALLA TION INSTRUCTIONS Continued Figure 13 - T ypical Horizontal T ermination Cap Mounting with Additional Siding Standoff Installed Siding Standoff Screw.
www .desatech.com 1 16238-01E 13 CORNER INST ALLA TION Recommended Applications: • Corner ground oor installation • G ro un d o or in st a ll at io n w he re pi p e ve nt s ho ri zo n - ta .
www .desatech.com 1 16238-01E 14 VENTING INST ALLA TION INSTRUCTIONS Continued Horizontal (H Horizontal (H Horizontal (H 5' min.
www .desatech.com 1 16238-01E 15 TERMINA TION Note: V ertical restrictor must be installed in all vertical installations. 1. Determine the route your vertical venting will take.
www .desatech.com 1 16238-01E 16 5. Pla ce th e as hing ov er th e pip e sec tion( s) extendin g through the roof. Secure the base of the ashing to the roof and framing with roof - ing nails. Be sure roo ng materia l over laps the top edge of the ashing as shown in Figure 19, page 15.
www .desatech.com 1 16238-01E 17 VENTING INST ALLA TION INSTRUCTIONS Continued Note : Install restrictor into inner collar of replace as shown. 5' min.
www .desatech.com 1 16238-01E 18 AND COMpONENTS .
www .desatech.com 1 16238-01E 19 FIREPLACE INST ALLA TION Us e pro per ga s typ e for the r ep la ce un it yo u are in st al li ng . If you hav e co n ic ti ng gas typ es , do not in st al l re plac e.
www .desatech.com 1 16238-01E 20 CA UTI ON: Nev er to uc h th e 9. Ch ec k to mak e sure th at the pow er cor d is com - pl et el y cl ea r of t he b lo we r wh ee l an d t hat t he re ar e no oth er for ei gn obj ect s in bl ow er whe el.
www .desatech.com 1 16238-01E 21 7. Che ck to ma ke su re t ha t th e po we r co rd is c om - pl ete ly c lea r of th e b low er w he el a nd t ha t th ere a re no ot he r f or ei gn o bj ec ts i n b lo we r wh ee l .
www .desatech.com 1 16238-01E 22 Figure 30 - External Regulator with V ent Pointing Down (Propane/LP Only) Propane/LP Supply T ank External Regulator V ent Pointing Down CAUTION: Use only new , .
www .desatech.com 1 16238-01E 23 FIREPLACE INST ALLA TION Continued .
www .desatech.com 1 16238-01E 24 pRESSURE TESTING FIREpLACE GAS CONNECTIONS 1. Open equipment shutof f valve (see Figure 33, page 23). 2. O pe n p ro p a ne / L P s u p pl y t an k v al v e f o r propane/LP fireplace or main gas valve located on or near gas meter for natural gas replace.
www .desatech.com 1 16238-01E 25 4. Remount the new frame at the hinge with ve new s crew s bef ore c losin g do or . Th is wi ll ensure seating of the gasket. 5. Cl os e gla ss doo r fra me. Lo ck la tc he s by pl ac in g the bar unde r the tab on doo r and pus hin g down and b ack on latch (see Figur e 37, page 2 4).
www .desatech.com 1 16238-01E 26 7. Remove three screws from deector shield on the inside top of rebox. Set shield and screws aside. 8. Install rear brick panel rst. Rest bottom edge of panel on back edge of burner assembly (see Figure 39). 9.
www .desatech.com 1 16238-01E 27 EV2 EV1 ORANGE IGNITOR LEAD GREEN PILOT TRANSFORMER IS1070B SYNETEK CONTROLS INC 24V AC E4 E2 E3 E6 RED E8 E12 BLUE 120V AC GROUND BLACK WHITE WIRING DIAGRAM.
www .desatech.com 1 16238-01E 28 6. W ait ve (5)minutes toclear outany gas. Then smell for gas, including near the oor . Ifyousmell gas,STOP!Follow“B”inthe safet y inform ation in column 1.
www .desatech.com 1 16238-01E 29 Figure 45 - T ypical Flame Pattern OpTIONAL REMOTE OpERA TION Note: The WRC receiver and hand-held re - motecontr olkitmust bepurchased separately (see Accessories , page 35).
www .desatech.com 1 16238-01E 30 C L E A N IN G AN D M A I N T EN AN C E .
www .desatech.com 1 16238-01E 31 Conduct annual inspection of the venting system following these guidelines: 1. Check areas of venting system that are ex - posed to the weather for corrosion (rust spots or streaks and, in extreme cases, holes).
www .desatech.com 1 16238-01E 32 Pilot will not stay lit No gas to burner , although wall switch and valve are set to the ON position Frequent pilot outage Fir epla ce produ ces a clicki ng/t ick - ing noise just after burner is lit or shut off Slight smoke or odor during initial operation REMEDY 1 .
www .desatech.com 1 16238-01E 33 TROUBLESHOO TING Continued .
www .desatech.com 1 16238-01E 34 REPLACEMENT P ARTS Note : Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty .
www .desatech.com 1 16238-01E 35 - Black - Brushed Brass - Platinu.
www .desatech.com 1 16238-01E 36 ILL USTRA TED P ARTS BREAKDOWN .
www .desatech.com 1 16238-01E 37 P ARTS LIST This list contains replaceable parts used in your replace.
www .desatech.com 1 16238-01E 38 7 15 10 12 1 12 2 3 13 9 1 1 6 12 14 18 17 17 18 19 20 16 14 8 4 5 22 23 24 21 31 33 32 30 29 28 25 27 26 ILL USTRA TED P ARTS BREAKDOWN .
www .desatech.com 1 16238-01E 39 P ARTS LIST This list contains replaceable parts used in your replace.
2701 Industrial Drive P .O. Box 90004 Bowling Green, KY 42102-9004 www .desatech.com NOT A UPC 1 16238-01 Rev . E 03/06 WARRANTY INFORMA TION KEEP THIS WARRANTY Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory .
Un punto importante, dopo l’acquisto del dispositivo (o anche prima di acquisto) è quello di leggere il manuale. Dobbiamo farlo per diversi motivi semplici:
Se non hai ancora comprato il Desa (V)KC36PE SERIES, (V)KC36NE SERIES è un buon momento per familiarizzare con i dati di base del prodotto. Prime consultare le pagine iniziali del manuale d’uso, che si trova al di sopra. Dovresti trovare lì i dati tecnici più importanti del Desa (V)KC36PE SERIES, (V)KC36NE SERIES - in questo modo è possibile verificare se l’apparecchio soddisfa le tue esigenze. Esplorando le pagine segenti del manuali d’uso Desa (V)KC36PE SERIES, (V)KC36NE SERIES imparerai tutte le caratteristiche del prodotto e le informazioni sul suo funzionamento. Le informazioni sul Desa (V)KC36PE SERIES, (V)KC36NE SERIES ti aiuteranno sicuramente a prendere una decisione relativa all’acquisto.
In una situazione in cui hai già il Desa (V)KC36PE SERIES, (V)KC36NE SERIES, ma non hai ancora letto il manuale d’uso, dovresti farlo per le ragioni sopra descritte. Saprai quindi se hai correttamente usato le funzioni disponibili, e se hai commesso errori che possono ridurre la durata di vita del Desa (V)KC36PE SERIES, (V)KC36NE SERIES.
Tuttavia, uno dei ruoli più importanti per l’utente svolti dal manuale d’uso è quello di aiutare a risolvere i problemi con il Desa (V)KC36PE SERIES, (V)KC36NE SERIES. Quasi sempre, ci troverai Troubleshooting, cioè i guasti più frequenti e malfunzionamenti del dispositivo Desa (V)KC36PE SERIES, (V)KC36NE SERIES insieme con le istruzioni su come risolverli. Anche se non si riesci a risolvere il problema, il manuale d’uso ti mostrerà il percorso di ulteriori procedimenti – il contatto con il centro servizio clienti o il servizio più vicino.
