Manuale d’uso / di manutenzione del prodotto 186843 del fabbricante Weed Eater
Vai alla pagina of 48
MODEL NO . WET1742ST A 17.0 HP 42 Inc h La wn T ractor 186843 Re v . 1 6.9.03 JH/MH PRINTED IN U .S .A. ® F or P ar ts and Ser vice, contact our authorized distributor: call 1-800-849-1297 F or T ech.
2 • A v oid star ting or stopping on a slope. If tires lose trac- tion, disengage the blades and proceed slo wly straight down the slope . DO NO T : • Do not turn on slopes unless necessar y , and then, turn slowly and gradually downhill, if possib le .
3 W ARNING: In order to prevent ac- ci den tal star ting when setting up, trans por t ing, ad just ing or making re- pairs, al ways dis con nect spark plug wire and place wire where it can not contact spark plug. W ARNING: Do not coast do wn a hill in neutral, y ou ma y lose control of the tractor .
4 T ABLE OF CONTENTS SAFETY RULES ......................................................... 2-3 PRODUCT SPECIFICA TIONS ....................................... 4 CUST OMER RESPONSIBILITIES ................................. 4 ASSEMBL Y ................
5 CONTENTS OF HARD W ARE P A CK Steering Wheel Seat Keys Slope Sheet (1) Oil Drain Tube (1) Bolt (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Lock Washer 1/2 (1) Large Flat Washer (1) Hex Bolt 1/4-28 x 1-.
6 ASSEMBL Y T OOLS REQUIRED FOR ASSEMBL Y A sock et wrench set will mak e assembly easier . Stan dard wrench sizes are listed. (2) 7/16" wrenches Utility knif e (2) 3/4" wrench Tire pres sur.
7 ASSEMBL Y FIG. 2 T O R OLL TRA CT OR OFF SKID (See Op- er a tion section for location and func tion of con trols) • Press lift lev er plunger and r aise attachment lift le v er to its highest po si tion. • Release parking brake b y depressing clutch/brak e ped al.
8 ASSEMBL Y ✓ CHECKLIST BEFORE Y OU OPERA TE AND ENJO Y Y OUR NEW TRAC- T OR, WE WISH T O ASSURE THA T Y OU RECEIVE THE BEST PER FOR MANCE AND SA TISF A CTION FROM THIS QU ALITY PR OD UCT . PLEASE REVIEW THE FOLLO WING CHECKLIST : ✓ All assembly instructions hav e been completed.
9 OPERA TION These symbols ma y appear on your tr actor or in literature supplied with the product. Lear n and understand their mean- ing. DANGER, KEEP HANDS AND FEET AWAY FREE WHEEL (Automatic Models.
10 OPERA TION KNO W Y OUR TRA CT OR READ THIS O WNER'S MANU AL AND SAFETY RULES BEFORE OPERA TING Y OUR TRA CT OR Compare the illustrations with y our tractor to f amiliarize y ourself with the locations of v arious controls and ad just ments. Sav e this man ual f or future ref erence.
11 NO TE: Under cer tain conditions when tractor is standing idle with the engine running, hot engine exhaust gases ma y cause “brown ing” of g rass .
12 T O OPERA TE ON HILLS W ARNING: Do not drive up or do wn hills with slopes great er than 15° and do not drive across an y slope. • Choose the slowest speed bef ore star ting up or down hills. • Av oid stopping or changing speed on hills . • If slowing is necessary , mov e throttle control le v er to slower position.
13 OPERA TION T O ST ART ENGINE (See Fig. 5) When star ting the engine for the fi rst time or if the engine has run out of fuel, it will take e xtra cr anking time to mov e fuel from the tank to the engine. • Sit on seat in operating position, depress clutch/brak e pedal and set parking brake .
14 MAINTENANCE BEFO RE EAC H USE T R A C T 0 R Inspect Muffler/Spark Arrester Lubrication Chart Check Brake Operation Clean Air Filter Change Engine Oil (with oil filter) Replace Air Filter Paper Cart.
15 MAINTENANCE FIG. 9 FIG. 8 B A TTER Y Y our tractor has a batter y charging system which is suf fi cient f or normal use. Ho we v er , periodic charging of the batter y with an automotive charger will e xtend its life. • Keep battery and ter minals clean.
16 MAINTENANCE V- B E LT S Check V -belts for deterioration and wear after 100 hours and replace if necessar y . The belts are not adjustable. Re place belts if they begin to slip from w ear . TRANSAXLE COOLING K eep transaxle free from b uild-up of dir t and chaff which can restrict cooling.
17 MAINTENANCE CLEANING • Clean engine, batter y , seat, fi nish, etc. of all f oreign matter . • Keep fi nished surf aces and wheels free of all gasoline, oil, etc.
18 SER VICE AND ADJUSTMENTS W ARNING: T O A V OID SE RI OUS IN JU R Y , BEFORE PERFORMING ANY SER VICE OR ADJUST - MENTS: • Depress clutc h/brake pedal fully and set parking brake. • Place gearshift lever in neutral (N) position. • Place attachment c lutch in “DISENGAGED” position.
19 T O REPLA CE MO WER BLADE DRIVE BEL T (See Fig. 18) The mower b lade drive belt ma y be replaced without tools. P ark the tractor on le v el surf ace. Engage parking brake . BEL T REMO V AL - • Remov e mower from tractor (See “T O REMO VE MO W ER” in this section of this manual).
20 SER VICE AND ADJUSTMENTS FIG. 18 T O REPLA CE MO TION DRIVE BEL T (See Fig. 20) P ark the tractor on le v el surf ace. En gage par king brak e. Fo r a s sis tance, there is a belt installation guide decal on bottom side of left f ootrest. BEL T REMO V AL - • Remove mower (See “TO RE MO VE MO WER” in this section of manual).
21 FIG. 20 ADJUSTMENT BOL T NEUTRAL LOCK GA TE GEARSHIFT LEVER FIG. 21 SER VICE AND ADJUSTMENTS TRANSAXLE PULLEY ST A TION ARY IDLER CLUTCHING IDLER ENGINE PULLEY CENTER SP AN KEEPER TRANSAXLE GEAR SHIFT LEVER NEU TRAL- ADJUSTMENT (See Fig. 21) The transaxle should be in neutral when the gear shift le v er is in neutral (N) (loc k gate) position.
22 FIG. 23 SER VICE AND ADJUSTMENTS REPLA CING B A TTER Y (See Figs. 24 and 25) W ARNING: Do not short battery ter mi nals by allowing a wrenc h or any other object to contact both terminals at the same time. Bef ore connect- ing battery , remove metal bracelets, wristwatch bands, rings, etc.
23 SER VICE AND ADJUSTMENTS ENGINE T O AD JUST THR O TTLE CON TROL CABLE The throttle control has been preset at the f actor y and ad just ment should not be necessar y . If adjustment is nec- es sar y , see engine manual. T O AD JUST CHOKE CON TROL The choke control has been preset at the f actory and ad- just ment should not be necessar y .
24 ST ORA GE Immediately prepare your tr actor f or storage at the end of the season or if the tractor will not be used f or 30 da ys or more. W ARNING: Ne ver store the trac tor with gas o line in the tank inside a building where fumes may reac h an open fl ame or spark.
25 TR OUBLESHOO TING POINTS Will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “CHOKED” properly . 2. See “T O ST ART ENGINE” in Oper ation section. 3. Engine fl ooded. 3. W ait se ver al minutes bef ore attempting to star t. 4. Bad spar k plug.
26 TR OUBLESHOO TING POINTS PROBLEM CA USE CORRECTION Engine continues to run 1. F aulty oper ator-safety presence control system. 1. Check wiring, switches and connections. If not when operator leaves seat corrected, contact an authorized service center/ with attachment clutc h depar tment.
27 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A SCHEMA TIC BATTERY FUSE IGNITION SWITCH RED RED RED BLACK IGNITION UNIT HEADLIGHTS REMOVABLE CONNECTIONS BLACK BLACK BLACK WHITE WHITE WHITE RE.
28 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A ELECTRICAL 28 29 26 24 42 43 27 27 25 41 27 27 40 33 90 30 8 2 1 27 16 16 52 48 22 21.
29 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A ELECTRICAL 1 163465 Battery 12 V olt 28 Amp 2 74760412 Bolt He x Hd 1/4-20unc X 3/4 8 176689 Bo x Battery 16 176138 Switch Interlock Push -In 2.
30 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A CHASSIS AND ENCLOSURES 26 25 64 208 13 208 11 1 3 2 9 208 209 209 209 5 5 207 3 3 3 142 3 3 3 142 17 29 28 12 51 57 53 52 54 55 145 37 3 37 24 26 25 31 24 30 35 3 26 33 10 26 34 35 18 14 38 14 206 212 chassis-pl.
31 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A CHASSIS AND ENCLOSURES 1 174619 Chassis 2 176554 Dra wbar 3 17060612 Scre w 3/8-16x.75 5 155272 Bumper Hood/Dash 9 168336X010 Dash P/L 10 72140.
32 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A DRIVE 29 28 112 14 41 38 39 57 51 74 75 78 76 77 1 25 19 24 2 53 35 34 37 36 35 62 36 59 212 55 77 61 22 27 26 6 113 18 51 5 18 6 85 52 30 32 3.
33 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A DRIVE KEY P ART NO . NO . DESCRIPTION KEY P ART NO . NO . DESCRIPTION 1 - - - - - - T ransaxle P eerless (206-545C) (Order par ts from transaxl.
34 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A STEERING ASSEMBL Y 44 51 54 5 9 5 7 7 9 4 3 32 43 6 43 8 10 40 11 8 6 9 46 46 8 6 9 2 47 47 26 30 28 1 41 42 37 36 37 38 12 39 68 67 67 67 13 6.
35 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A STEERING ASSEMBL Y 1 140044X428 Wheel Steering Auto Blac k 2 175131 Axle Asm F ront 3 169840 Spindle Asm Lh 4 169839 Spindle Asm Rh 5 6266H Bea.
36 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A ENGINE 2 1 OPTIONAL EQUIPMENT Spark Arrester 29 44 46 32 31 33 37 33 40 62 13 4 85 78 78 81 3 16 23 45 14 38.
37 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A ENGINE NO TE: All component dimensions giv en in U .S . inches 1 inch = 25.4 mm 1 170551 Control Throt /Ch Flag 2 17720408 Scre w He x Thd Cut .
38 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A SEA T ASSEMBL Y KEY P ART NO . NO . DESCRIPTION KEY P ART NO . NO . DESCRIPTION 14 72050412 Bolt Rdhd Sht Nk 1/4-20 x 1-1/2 15 134300 Spacer Sp.
39 5 11 16 6 9 12 3 10 7 14 WHEELS & TIRES KEY P ART NO . NO . DESCRIPTION KEY P ART NO . NO . DESCRIPTION 6 2 1 5,8 4,10 3,9 1 1 7 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A DECALS 20 1 4 4 KEY P ART NO .
40 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A MO WER LIFT 15 20 16 17 18 20 20 15 20 4 5 6 2 3 1 6 5 4 7 8 12 11 31 32 31 32 19 19 13 13 13 13.
41 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A MO WER LIFT 1 159460 Wire Asm Inner/Sprg w/Plunger 2 159471 Shaft Asm Lift 3 105767X Pin Groov e 4 12000002 E Ring #5133-62 5 19211621 W asher 21/32 x 1 x 21 Ga.
42 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A MO WER DECK 15 14 13 11 10 9 8 16 68 37 184 30 31 32 33 146 148 145 150 45 144 147 147 142 149 142 54 52 53 55 56 34 1 46 44 21 24 25 26 27 2 2.
43 REP AIR P ARTS TRA CT OR - - MODEL NUMBER WET1742ST A MO WER DECK 1 165892 Mow er Deck Assemb ly , 42" 2 72140506 Bolt 3 138017 Brac k et Asm F r .
44 SER VICE NO TES.
45 LIMITED W ARRANTY The Manuf acturer warr ants to the original consumer purchaser that this product as manufactured is free from def ects in materi- als and work man ship .
46 T E C U M S E H ® Issued Jan uar y 1980 Re vised January 1991 T E C U M S E H ® SERVICE POLICY POLICY W ARRANTY LIMITED W ARRANTIES FOR NEW PEERLESS GEAR PO WER TRAIN COMPONENTS A.
47 15 DEGREES MAX. FOLD ALONG DOTTED LINE THIS IS A 15 DEGREE SLOPE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face.
®.
Un punto importante, dopo l’acquisto del dispositivo (o anche prima di acquisto) è quello di leggere il manuale. Dobbiamo farlo per diversi motivi semplici:
Se non hai ancora comprato il Weed Eater 186843 è un buon momento per familiarizzare con i dati di base del prodotto. Prime consultare le pagine iniziali del manuale d’uso, che si trova al di sopra. Dovresti trovare lì i dati tecnici più importanti del Weed Eater 186843 - in questo modo è possibile verificare se l’apparecchio soddisfa le tue esigenze. Esplorando le pagine segenti del manuali d’uso Weed Eater 186843 imparerai tutte le caratteristiche del prodotto e le informazioni sul suo funzionamento. Le informazioni sul Weed Eater 186843 ti aiuteranno sicuramente a prendere una decisione relativa all’acquisto.
In una situazione in cui hai già il Weed Eater 186843, ma non hai ancora letto il manuale d’uso, dovresti farlo per le ragioni sopra descritte. Saprai quindi se hai correttamente usato le funzioni disponibili, e se hai commesso errori che possono ridurre la durata di vita del Weed Eater 186843.
Tuttavia, uno dei ruoli più importanti per l’utente svolti dal manuale d’uso è quello di aiutare a risolvere i problemi con il Weed Eater 186843. Quasi sempre, ci troverai Troubleshooting, cioè i guasti più frequenti e malfunzionamenti del dispositivo Weed Eater 186843 insieme con le istruzioni su come risolverli. Anche se non si riesci a risolvere il problema, il manuale d’uso ti mostrerà il percorso di ulteriori procedimenti – il contatto con il centro servizio clienti o il servizio più vicino.
